Home
Mercury
Outboard Motor
HP700 SCi
Mercury HP700 SCi User Manual
4
of 1
of 1 rating
138 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
MAINTENANCE
91
2.
Install
the
bushing
and
secure
with
the
retaining
ring
as
shown.
a
b
c
d
21686
a -
Propeller
b -
Adaptor
c -
Bushing
d -
Retaining ring
3.
Coat the propeller shaft splines with Anti‑Corrosion Grease.
4.
Install the propeller/adaptor assembly to the propeller shaft.
a
c
d
e
f
21685
b
a -
Nylon nut
b -
Jam nut
c -
Washer
d -
Adaptor
e -
Bushing
f -
Retaining ring (installed
in propeller)
Tube Ref
No.
Description
Where Used
Part No.
94
Anti-Corrosion
Grease
Propeller shaft
splines
92-802867Q 1
98
100
Table of Contents
Table of Contents
5
Warranty Registration United States and Canada
9
Warranty Information
9
Transfer of Warranty
10
Mercury Racing Division One Year Limited Warranty
10
Products Sold to Government Agencies
14
Warranty against Corrosion (Worldwide)
14
Warranty Coverage and Exclusions for Mercury Racing Sterndrive Products
15
California Emission Control Warranty Statement
16
Star Label
19
Boater's Responsibilities
21
Boat Horsepower Capacity
21
General Information
21
High-Speed and High-Performance Boat Operation
22
Lanyard Stop Switch
22
Trailering Boat
23
Protecting People in the Water
24
Exhaust Emissions
24
Wave and Wake Jumping
26
Impact with Underwater Hazards
27
Safe Boating Suggestions
29
Stolen Power Package
32
Power Package Identification
33
Specifications
33
General Engine Specifications (HP700)
35
Engine Operating Limitations (HP700)
36
Fuel Requirements
36
Low Permeation Fuel Hose Requirement
38
Oil Recommendations
39
Capacities
40
After Break-In Period
41
Engine Break-In
41
Instrumentation
42
Warning System
42
Operation
42
Electrical System Overload Protection
45
Remote Controls (Console Mounted Zero Effort)
48
Power Trim
49
Starting, Shifting and Stopping
54
Operation Chart
56
Freezing Temperature Operation
57
Drain Plug and Bilge Pump
57
Launching and Boat Operation Care
57
Weight Distribution
58
Bottom of Boat
58
Cavitation
58
Conditions Affecting Operation
58
Ventilation
59
Propeller Selection
59
Conditions that Lower Engine Performance
60
Servicing High Horsepower Engines
61
Service Responsibilities
61
Replacement Service Parts
62
Do-It-Yourself Maintenance Suggestions
62
Maintenance Charts
64
Checking Fluid Levels
69
Changing Fluids
80
Lubrication Points
96
Sterndrive Cleaver Propeller Installation (NXT¹)
97
Cleaver Propeller Installation (SSM)
100
Flushing Cooling System
102
Seawater Pump Impeller Inspection
102
Cleaning the Seawater (Raw Water) Section of the Engine Oil, Power Steering, Fuel, and Transmission Coolers
103
Serpentine and Supercharger Drive Belts
106
Fuel Filters
109
Corrosion and Corrosion Protection
113
Battery
116
Bottom of Boat
117
Inspection and Maintenance
117
Attention Required after Submersion
118
Power Package Lay-Up
119
Cold Weather or Extended Storage
119
Cooling System Draining Instructions
122
Battery Storage
126
Power Package Recommissioning
126
Engine will Not Crank
129
Engine Cranks but will Not Start
129
Troubleshooting
129
Engine Hard to Start, Runs Rough, Misses, And/Or Backfires
130
Poor Performance
130
Engine Coolant Temperature too Low
130
Engine Coolant Temperature too High
131
Low Engine Oil Pressure
131
Power Trim Does Not Operate (Motor Doesn't Run)
132
Battery will Not Come up on Charge
132
Power Trim Does Not Operate (Motor Runs but Drive Unit Does Not Move)
132
Electrical Analog Trim Gauge Malfunction
132
Remote Control Operates Hard, Binds, Has Excessive Free-Play or Makes Unusual Sounds
133
Steering Wheel Turns Hard or Jerky
133
Seawater Pressure Is below Specification
133
Local Repair Service
134
Service Away from Home
134
Parts and Accessories Inquiries
134
Service Assistance
134
Owner Service Assistance
134
Mercury Mercruiser Service Offices
135
United States and Canada
137
Outside the United States and Canada
137
Ordering Literature
137
Maintenance Log
138
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mercury HP700 SCi and is the answer not in the manual?
Ask a question
Mercury HP700 SCi Specifications
General
Brand
Mercury
Model
HP700 SCi
Category
Outboard Motor
Language
English
Related product manuals
Mercury 225 HP
16 pages
Mercury 115 HP
23 pages
Mercury 30 - 60 HP
16 pages
Mercury Marathon 40 HP
81 pages
Mercury 4-Stroke 9.9 HP
6 pages
Mercury 5 HP FourStroke Propane
61 pages
Mercury 300R HD CMS Mechanical
99 pages
Mercury 40
106 pages
Mercury 75
159 pages
Mercury 50
106 pages
Mercury Optimax
121 pages
Mercury 25 4-Stroke
72 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
