Parker Hannifin Corporation
Chelsea Products Division
Olive Branch, MS 38654 USA
9
Bulletin HY25-1650-M1/US
Installation Sketch
NOTES:
1) For Installation Parts Refer to Kits:
328929-12X & -24X = Installation Kit
329049X = Special Fitting Kit
2) Direction of Oil Flow
3) Strip Wire Ends 0.25" Prior to Installing Connector
Electronic Over Speed Control (E.O.C.) Installation
Sketch for 270 Series 12 and 24 Volt AISIN Automatic
Transmission (Models A443, A445 & A450-43LE)
(SK-469)
379749
Male Connector
IN CYL
EXH
FROM TRANSMISSION (HIGH PRESSURE) -TO- VALV E (INLET)
FROM VALVE -TO-
P.T.O. (INLET PORT-A)
328923-10X MALE & FEMALE CONNECTOR CABLE (10 FT.)
SUPPLIED WITH SPEED LIMITER
OPTIONAL: 328923-5X CABLE (5 FT.)
MUST BE ORDERED SEPERATE BY CUSTOMER
FROM VALV E (EXHAUST) -TO- P. T . O. (DUMP PORT-B)
Ground
379253
Ring Connector
329087X
Pressure Hose
379449
Screened
Adapter
379254-3
14 AWG Wire, Green
with Butt Connector
Connector
with 2-Wire
Shielded Cable
16 AWG Wire, Red
Connect to 12 VDC or
24 VDC, 5A Minimum
Ignition Circuit
Ground
16 AWG Wire, Black
with Ring Connector
Electronic Overspeed
Controller - 329650X
(1.0")
(1.8")
(4.9")
16 AWG Wire, Green
with Butt Connector
379258
Mounting Bracket
500457-6 (2)
Mounting Screw
500357-1 (2)
Lock Washer
.250"- 18 NPTF
379280
Flare Fitting
379686-1 12 Volt (Green)
379686-2 24 Volt (Black)
379280
Flare Fitting
16 AWG Wire, Blue
with Butt Connector
379254-13
16 AWG Wire,
Blue with
Ring Connector
379547
Pressure
Switch
Port A
On Closed
Bearing Cap
329087X
Pressure Hose
.125"-27 NPTF
378966
Street Tee
Screened
Ground
Drill 1" Hole
in Firewall for 379265 Grommet
379265 Grommet
- Slice Grommet
- Insert Wires
- Push into Hole thru Firewall
379254-14
14 AWG Wire, Black
with 2-Ring Connectors
Port C
P.T.O. Mounting Surface S.A.E. 6 Bolt
P.T.O. Opening Remove Cover on
Transmission Before Installing P.T.O.
High Pressure Port
379749
Male Connector
329130-5X
High Pressure
Hose Ass'y
.125"- 27 NPTF
Port B
379243 Speed Sensor Locate over
Gear Teeth
NOTE: Insert Hose Fittings at Plastic Plug
Locations (Remove & Discard Plugs)
Chelsea Power-Take-Off
Model: 270 Series/Rear View of P.T.O.
329087X Pressure Lube Hose Connect to
Low Pressure Port on Transmission and to
P.T.O. Idler Shaft Lube Port “C”
Aisin Automatic Transmission
Rear View
Low Pressure Port
Top View Left View
Line Pressure
▼
Lube Pressure
▼
Owner’s Manual
Electronic Overspeed Control
To Next Page
Loading...
