4.2
ELECTRONIC FUEL INJECTION
GENERAL INFORMATION
Special Tools
IMPORTANT: For the most recent information on
Digital Wrench
™ software and fileset downloads
please visit the website: www.polaris.diagsys.com
TPS Tester Adapter Harness - PU-47082
This tester allows the use of a digital multi-meter to test TPS
function as well perform the TPS adjustment procedure.
NOTE: Voltage Regulator (4010264) is required if
using TPS Tester Adapter Harness (PU-47082).
If your dealership sells Polaris snowmobiles, you
may already have this regulator from TPS Tester Kit
(2201519). If you do not have this regulator, you
must order one from SPX at 1-800-328-6657.
WARNING
* Gasoline is extremely flammable and explosive
under certain conditions.
* EFI components are under high pressure. Verify
system pressure has been relieved before
disassembly.
* Never drain the fuel system when the engine is hot.
Severe burns may result .
* Do not overfill the tank. The tank is at full capacity
when the fuel reaches the bottom of the filler neck.
Leave room for expansion of fuel.
* Never start the engine or let it run in an enclosed
area. Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness and
death in a short time.
* Do not smoke or allow open flames or sparks in or
near the area where refueling is performed or where
gasoline is stored.
* If you get gasoline in your eyes or if you should
swallow gasoline, seek medical attention immediately.
* If you spill gasoline on your skin or clothing,
immediately wash with soap and water and change
clothing.
* Always stop the engine and refuel outdoors or in a
well ventilated area.
PART
NUMBER
TOOL DESCRIPTION
PU-47082 TPS Tester Adapter Harness
4010264 TPS Tester Regulator
PU-43506-A Fuel Pressure Gauge Kit
PV-48656 Fuel Pressure Gauge Adaptor
PU-47063
Digital Wrench
™ Diagnostic Software
(Includes most recent version of software
and a serial number)
PU-47471
Digital Wrench
™ SmartLink Module Kit
(PU-47470, PU-47469, PU-47468)
PU-47470
Digital Wrench
™
PC Interface Cable
PU-47469
Digital Wrench
™
Vehicle Interface Cable
PU-47468
Digital Wrench
™
SmartLink Module
To Next Page
Loading...
