PoolPak R-410A SWHP Series - Page 6

IV EGW05-SWHPEG-20140724
TM
TM
LIST OF FIGURES
Figure 2-1. Dew Point Control Psychrometric .............................................................................................................................. 9
Figure 2-2. SWHP SR System Schematic ................................................................................................................................... 11
Figure 2-3. SWHP SEP System Schematic ................................................................................................................................. 11
Figure 2-4. Typical PoolPak™ Rooftop Installation ...................................................................................................................... 15
Figure 3-1. Air Cooled Condenser Dimensions - End View ......................................................................................................... 25
Figure 3-2. Air Cooled Condenser Dimensions - Side View ....................................................................................................... 25
Figure 3-3. Remote Cooling Tower Dimensions .......................................................................................................................... 26
Figure 3-4. PoolPak™ Optional Water-Cooled Condenser Cabinet - Attached ........................................................................... 27
Figure 4-1. Field Wiring Diagram ................................................................................................................................................. 37
Figure 4-2. Pool Water Piping Schematic .................................................................................................................................... 39
Figure 4-3. Negative Pressure Condensate Piping Schematic .................................................................................................... 40
Figure 4-4. Remote ACC Installation Around Walls or Obstructions ............................................................................................ 41
Figure 4-5. Remote ACC Installation When Installing Multiple Units ...........................................................................................41
Figure 4-6. Remote ACC Installation When Installing Units in Pits .............................................................................................. 42
Figure 4-7. Remote ACC Installation When Installing Units Near Decorative Fences ................................................................. 42
Figure 4-8. Remote ACC Above Unit ........................................................................................................................................... 44
Figure 5-1. Remote Interface Unit Graphic .................................................................................................................................. 47
Figure 5-2. Data Retrieval Using USB Key .................................................................................................................................. 59
Figure 6-1. Single Point Power Connection ................................................................................................................................. 63
Figure 6-2. Dual Point Power Connection ................................................................................................................................... 63
Figure 6-3. Remote Connections ................................................................................................................................................. 64
Figure 6-4. Multiple Unit Interface ................................................................................................................................................ 65
LIST OF TABLES
Table 1-1. Typical Pool Water and Air Temperature Set-Points ................................................................................................... 2
Table 1-2. Recommended Pool Water Chemistry ........................................................................................................................ 3
Table 3-1. PoolPak™ SWHP Unit Capacity ................................................................................................................................. 17
Table 3-2. Pool Water Condenser Pressure Drop and Heat Capacity ......................................................................................... 18
Table 3-3. PoolPak™ Auxiliary Gas Furnace Capacity ................................................................................................................ 19
Table 3-4. PoolPak™ Auxiliary Electric Heat Capacity ................................................................................................................ 19
Table 3-5. ACC - Model SWHP 0060 ........................................................................................................................................... 20
Table 3-6. ACC - Model SWHP 0080 ........................................................................................................................................... 20
Table 3-7. ACC - Model SWHP 0100 ........................................................................................................................................... 21
Table 3-8. ACC - Model SWHP 0120 ........................................................................................................................................... 21
Table 3-9. ACC - Model SWHP 0140 ........................................................................................................................................... 22
Table 3-10. ACC - Model SWHP 0190 ......................................................................................................................................... 22
Table 3-11. ACC - Model SWHP 0220 ......................................................................................................................................... 23
Table 3-12. ACC - Model SWHP 0260 ......................................................................................................................................... 23
Table 3-13. ACC - Model SWHP 0300 ......................................................................................................................................... 24
Table 3-14. ACC - Model SWHP 0340 ......................................................................................................................................... 24
Table 3-15. Remote Water Cooled Condenser Dimensions ........................................................................................................ 26
Table 3-16. WCC Piping Connections.......................................................................................................................................... 26
Table 3-17. Water Cooled Condenser Performance .................................................................................................................... 28
Table 4-1. Pipe Sizes for Remote Refrigerant Condensers ......................................................................................................... 44
Table 4-2. Remote ACC Refrigerant (R-410A) Charge ................................................................................................................ 45
Table 4-3. Refrigerant (R-410A) Charge for Different Line Sizes ................................................................................................. 45
Table 5-1. Recommended Pool Water Chemistry ........................................................................................................................ 60