To navigate between hyperlink topics using a keyboard, select ALT+◄ or ALT+►.
40
Table of Contents
TRANSPORTATION AND STORAGE
Transporting the Generator
To prevent fuel spillage when transporting, the generator should be secured upright in its normal operating position
with the ignition switch and the remote switch in the OFF position.
CO
▲ Do not operate the generator while it is on or in a vehicle.
▲ If you must transport the generator in an enclosed vehicle, drain all fuel from the generator.
▲ Avoid storing the generator in an enclosed area or vehicle. Gasoline is extremely flammable and explosive
under certain conditions. High temperatures inside could cause residual fuel to vaporize resulting in possible
explosion.
▲ Avoid placing the generator in direct sunlight when storing.
▲ Keep cigarettes, sparks, and any source of ignition away from generator and the fuel tank at all times.
Exercising the Generator
It is essential that you exercise the generator on a regular basis, which helps to:
• Maintain the charge for the 12V battery
• Prevent accumulation of varnish or sludge in the fuel system
• Remove moisture from the generator windings
• Keep the engine seals and moving components lubricated
Exercise the generator by running it with at least a 1/2 load (1200W) for 15 minutes per month.
Short-Term Storage
During short term storage, the generator should be secured upright in its normal operating position with the ignition
switch and the remote switch in the OFF position.
Long-Term Storage
During long term storage, the generator should be secured upright in its normal operating position with the ignition
switch and the remote switch in the OFF position.
▲ When the generator is used infrequently, it is important to add a fuel stabilizer, such as STA-BIL® Fuel
Stabilizer, to help prevent fuel oxidation (breakdown) and the formation of gum and varnish, and to inhibit
corrosion in the fuel system.
1. Be sure the storage area is free of excessive humidity and dust, and out of direct sunlight.
2. Depending on long how you are storing the generator, decide if you want to keep fuel in the fuel tank.
When storing up to one year:
– Keep the tank about 95% full to help prevent condensation during storage, leaving a little room at the top of the tank for fuel
to expand on hot days.
– Add a gasoline fuel treatment (such as STA-BIL
®
) to prevent contamination of your fuel supply, and run the generator for a
few minutes to push the as treatment through the fuel system.
When storing for more than one year:
– Drain fuel completely until no fuel remains in the fuel tank or fuel system.
3. Change the engine oil.
4. Remove the spark plug and pour about a tablespoon of clean engine oil into the cylinder.
5. Crank the engine several revolutions to distribute the oil and then reinstall the spark plug.
6. Slowly pull the starter grip until resistance is felt. At this point, the piston is coming up on its compression stroke and both the intake
and exhaust valves are closed. Storing the engine in this position will help to protect it from internal corrosion.
7. Once a month, use a trickle charger to recharge the 12V battery.
To Next Page
Loading...
