RedEarth BlackMax - Safety instructions; Lifting hazard; Fire safety; Damaged battery handling

BlackMax – Installation and Operation Manual
Page 2 of 36
Issue date: 24/11/2023. Version 13.0
Safety instructions
The wiring diagrams and installation instructions are given as a guide only and compliance to appropriate standards is
the responsibility of the installer. Relevant standards are listed below:
AS/NZS 3000:2018
Wiring rules
AS/NZS 5033:2021
Installation and safety requirements for photovoltaic (PV) arrays
AS/NZS 4509.2:2012
Stand-alone power systems-Design
AS/NZS 1170.2:2021
Structural design actions-Wind actions
AS/NZS1768:2021
Lightning protection
AS/NZS 3008.1.2:2017
Electrical installations – Selection of cables
AS/NZS 5139:2019
Electrical installations-Safety of battery systems for use with power
conversion equipment
The BlackMax must only be installed by suitably qualified personnel who have read and are familiar with its operation
and hazards.
The BlackMax must only be installed by suitably qualified personnel who have read and are familiar with its operation
and hazards.
This manual covers all following model numbers: BMX-104, BMX-108, BMX-112.
In our efforts towards constant product enhancement, this document is subject to change at any time. Please visit
www.redearth.energy and download the appropriate and latest version manual.
Lifting hazard
The BlackMax is heavy. Observe proper lifting techniques. To reduce
the weight the Troppo batteries can be removed via the panel in the
rear of the system.
Fire
The BlackMax uses RedEarth's Troppo battery. This is a lithium-iron-
phosphate based battery (LFP). It is the safest lithium chemistry.
However, in the case of a fire the following steps should be taken. A dry
agent fire extinguisher should be readily available and used. DO NOT use
water. Evacuate the area and call emergency services. To x i c gas may be
produced if the battery catches fire.
Note:
The SDS document for the Troppo Battery can be found at
www.redearth.energy
Damaged battery
Do not use a damaged battery. Batteries should only be disposed of at
an appropriate recycling centre. Please contact RedEarth for advice.
WARNING:
Working on the inside of the BlackMax system is restricted to qualified personnel.
RedEarth recommend installation by licensed electricians only.