Document: 006-0211-00 Rev AD Page 3 of 62
Table of Contents
INTRODUCTION ............................................................................................................. 5
Customer Service/Support ........................................................................................... 5
BENCH TESTING AND VERIFICIATION PROCEDURES ............................................. 6
Tools Required ............................................................................................................ 6
Process Steps for Bench Test and Verification ............................................................ 6
INSTALLATION PROCEDURES FOR DOWNHOLE GAUGE ....................................... 8
Installing the ESP Sensor to the Motor ........................................................................ 9
Installing the Sensor Discharge Pressure Base Adapter (For ESP& QESP-3500
Gauge Models Only) .................................................................................................. 11
Installing the Resistance Temperature Detector “RTD” (For Non-Factory Installed
RTDs, Probe Style) .................................................................................................... 13
Wye Point Replacement ................................................................................................... 15
INSTALLING THE SURFACE INTERFACE EQUIPMENT ........................................... 19
SCOUT-3000 Installation ........................................................................................... 19
SPS-3000 Installation ................................................................................................ 19
SPS-1500 Installation ................................................................................................ 21
SCOUT-2200 Installation ........................................................................................... 22
INSTALLING THE SURGE SUPPRESSOR AND SURFACE CHOKE ........................ 23
Surface Choke ........................................................................................................... 26
Surge Panel Protector/Suppressor ............................................................................ 23
Surface Choke and Surge Protector Panel Assembly #90B2175 .............................. 25
SCOUT-3000 RELAY ALARMS SETUP ...................................................................... 28
SOFTWARE AND FIRMWARE INSTALLATION AND UPDATES .............................. 28
Scout-3000 (for Rev. A Only) ..................................................................................... 30
Updating SPS Firmware Using Tera Term - TTermpro ..................................................... 30
Updating LCD Firmware ............................................................................................ 32
Scout-3000 (for Rev. B and Later Versions) .............................................................. 40
Updating RCM Firmware with Memory Tools & USB Cable .......................................... 40
SPS-1500 .................................................................................................................. 40
Updating SPS-1500 Firmware Using Hyper-Terminal Utility ............................................. 41
Updating SPS-1500 Using Tera Term - TTermpro ............................................................ 44
Procedure for Viewing USB Memory with Memory Tools Software ........................... 46
4-20 mA CARD INSTALLATION AND CONFIGURATION .......................................... 47
Installing 4-20mA optional cards into the Scout-3000 ................................................ 47
Scout-3000 4-20mA Port Setup ................................................................................. 50
TROUBLESHOOTING .................................................................................................. 51
Sensor To Surface Communication Troubleshooting ................................................ 51
Scout-3000 Troubleshooting ...................................................................................... 52
SPS-1500 Troubleshooting ........................................................................................ 55
SCOUT and SPS Error Codes and Corrective Actions .............................................. 56
To Next Page
Loading...
