Maintenance Section 4
4-2
Part Number 020005256 5/15
MONTHLY CLEANING
Clean and sanitize the ice bin and cold plate:
1. Remove all ice from the ice bin.
2. Remove the ice bin strainer by lifting it straight up.
3. Prepare a mild detergent solution using warm
(100°F) water.
4. Wash the ice bin using a sponge and the mild
detergent solution.
5. Wash the cold plate using a soft, nylon bristle brush
and the mild detergent solution.
6. Pour the remaining detergent solution in the drain
pan and watch for obstruction of flow.
7. With clean cloth soaked in clean water, rinse the ice
bin and cold plate. DO NOT pour bucket water
inside cabinet.
8. Prepare 2 gallons of sanitizing solution by mixing 1
ounce of household bleach (that contains 5.25%
sodium hypochlorite) with 2 gallons of 120°F water.
The mixture should not exceed 100 PPM of chlorine.
9. With clean cloth soaked in sanitizing solution,
sanitize the ice bin and cold plate. Leave in contact
on ice bin and cold plate surface for at least 10
seconds. DO NOT pour bucket sanitizer inside
cabinet.
10. Allow to air dry. Do not rinse.
CLEANING CHECKLIST
•Check CO
2
supply. If CO
2
supply is low, an arrow on
the primary regulator gauge will point to a shaded
area that reads “Low CO
2
” or “Change CO
2
Cylinder.”
• Check syrup supply.
• Clean drain pan, grid, and splash panel.
• Clean the valve nozzles and diffusers.
PREVENTIVE MAINTENANCE
Preventative maintenance is a vital part of keeping your
dispenser in top condition. Following the guidelines
below will assist you in continued trouble-free operation
of your unit.
1. Conduct daily maintenance of the machine.
2. Perform monthly maintenance of the machine.
3. Perform periodic maintenance and sanitizing of
beverage system.
4. Do not overfill the dispenser bin with ice.
5. Do not allow the dispenser to sit for prolonged
periods of non use with ice in the bin.
6. Do not allow ice to remain in the bin more than a day
in order to prevent ice from freezing together and/or
stagnant ice.
7. Do not pour bucket of water or to store water inside
of the cabinet.
Contact MBE at 1-800-367-4233 for more information
about our ProActive Maintenance Program.
Unplug unit before servicing or cleaning ice bin.
Ice bin contains parts that can move at any time and
will cause injury if hands are in the way.
When using cleaning fluids or chemicals, rubber
gloves and eye protection must be worn.
To Next Page
Loading...