Skov DA 2000 User Manual (English)

Questions and Answers:

R
Ryan KeithAug 13, 2025
Why won't my Skov DA 2000 Water Pump start?
- D
  David RobinsonAug 13, 2025
  Your Skov Water Pump might not start due to several reasons: * A blown fuse: Replace the fuse. * Disconnected supply voltage: Connect the supply voltage. * A defective cable: Replace the cable. * A defective plug/socket: Replace the plug/socket. * The pump is frozen: Thaw the pump and reset the protective motor switch. * The relay/protective motor switch is activated: Reset the protective motor switch.
U
urogersAug 17, 2025
What to do if Skov Water Pump stops shortly after starting?
- J
  jonesanthonyAug 17, 2025
  If your Skov Water Pump stops soon after starting, it could be due to: * Insufficient water supply: Check the filters and supply valve. * A missing phase: Check or change the fuse, and reset the protective motor switch. * Pump pressure being too high: Reduce the pressure. * Missing open ball valves/nozzles: Close the ball valves or mount the nozzles.
S
Stephanie RobersonAug 21, 2025
How to fix unstable pressure in Skov DA 2000?
- M
  melissabarrAug 21, 2025
  Unstable or jerky pressure in your Skov Water Pump can be caused by: * Insufficient or clogged water supply: Check the water amount, ensuring filters aren't empty. * A clogged water supply filter: Replace the filters. * Defective or dirty pump valves: Change or clean the valve.
R
Rebekah EllisAug 25, 2025
How to unclog nozzles on Skov DA 2000?
- T
  Troy CooperAug 25, 2025
  Clogged nozzles on your Skov Water Pump can be resolved by: * Removing the nozzle end and soaking it in a 1:4 solution of vinegar and water for 24 hours. Then, clean it with compressed air. * If the filter at the nozzle is clogged, replace the filter.
T
Tyler CrossAug 28, 2025
Why is my Skov Water Pump very hot and running jerkily?
- A
  Ashley MartinezAug 28, 2025
  If your Skov Water Pump is very hot and runs jerkily with varying pressures, the safety valve may be defective. This valve should open and direct water to the sewer when the pump reaches approximately 60°C. Replace the safety valve.
H
Henry DavisAug 31, 2025
Why don't nozzles atomize on Skov DA 2000 Water Pump?
- S
  sbrewerAug 31, 2025
  If the nozzles on your Skov Water Pump are not atomizing, the swivel may be stuck. Clean the nozzle end with the swivel in acetic acid.
J
jamesmillerSep 5, 2025
What to do if Skov DA 2000 Water Pump safety valve runs constantly?
- A
  alindseySep 5, 2025
  If water constantly runs from the safety valve of your cold Skov Water Pump, the safety valve is likely defective and needs to be replaced.
S
Susan HillSep 8, 2025
Why are the pipes moving on my Skov DA 2000 Water Pump?
- K
  Kristin WatsonSep 8, 2025
  If the pipes on your Skov Water Pump are moving, there may be air in the system. Bleed the system at the end nozzle to resolve this issue.

Skov DA 2000 Specifications

General

Brand	Skov
Model	DA 2000
Category	Water Pump
Language	English

Summary

1 Product Description

2 Product Survey

Product Accessories

Electronic Lime Decomposer

Device to break down lime crystals in water.

Chemical Filter with Non-Return Valve

Filter with a clear glass to check clogging and non-return valve.

Pump Accessories and Consumables

Phosphate Cartridge

Cartridge for reducing limescale on nozzles with continuous use.

External Filter Unit

Filter unit for water with impurities, equipped with a transparent glass.

Filter Cartridges and Oil

Various filter cartridges and SAE 15W-40 oil for pump maintenance.

3 Mounting Guide

Water Supply Requirements

Details on water pressure, pipe size, and quality parameters for the pump.

3 Mounting Guide

Recommended Tools

List of tools recommended for mounting the pump.

3 Mounting Guide

General Drawings and Principle Sketch

Visual overview and schematic diagram of the pump without frequency converter.

3 Mounting Guide

Pump with Frequency Converter Drawings

Visual overview and schematic diagram of the pump with an integrated frequency converter.

3 Mounting Guide

Pump Placement and Wall Mounting

Instructions on selecting a location and physically mounting the pump unit onto a wall bracket.

3 Mounting Guide

Pre-Start Checks and Operation

Procedures for initial checks, starting, and stopping the pump.

3 Mounting Guide

Pump Accessories and Safety Valve

Information on mounting accessories and the function of the bypass safety valve.

4 Installation Guide

Electrical Connection Safety

Guidelines for safe and compliant electrical hookup of the pump, including RCD requirements.

4 Installation Guide

Circuit Diagram: 1 x 230 V

Electrical wiring diagram for a 1x230V pump configuration.

4 Installation Guide

Detailed 1x230 Volt Wiring

Detailed circuit diagram for a 1x230V pump with component labels and functions.

4 Installation Guide

Circuit Diagram: 3 x 400 V

Electrical wiring diagram for a 3x400V pump configuration.

4 Installation Guide

Detailed 3x400 Volt Wiring

Detailed circuit diagram for a 3x400V pump with component labels and functions.

4 Installation Guide

Circuit Diagram: 3 x 220 V/3 x 230 V

Electrical wiring diagram for a 3x220V/3x230V pump configuration.

4 Installation Guide

Detailed 3x230 Volt Wiring

Detailed circuit diagram for a 3x230V pump with component labels and functions.

4.3 Pump with Frequency Converter

Circuit Diagram: 3 x 230 V

Electrical wiring diagram for a 3x230V pump with frequency converter.

4.3 Pump with Frequency Converter

Detailed 3x230 Volt Wiring

Detailed circuit diagram for a 3x230V pump with frequency converter and component labels.

4.3 Pump with Frequency Converter

Circuit Diagram: 3 x 400 V

Electrical wiring diagram for a 3x400V pump with frequency converter.

4.3 Pump with Frequency Converter

Detailed 3x400 Volt Wiring

Detailed circuit diagram for a 3x400V pump with frequency converter and component labels.

4.4 Multi-Section Cooling Control

Relay Mounting in Climate Controllers

Instructions for installing relays in climate controllers for multi-section pump operation.

Climate Controller Setup and Testing

Guidance on configuring and verifying climate controllers for the cooling system.

4.4 Multi-Section Cooling Control

System Wiring Diagram

Wiring diagram illustrating how multiple house sections connect to the cooling pump.

5 Testing Procedures

System Checks

Procedures for checking oil level, electrical cable, voltage, power consumption, and water supply.

Complete System Test

Steps to test the entire cooling system after installation, including pressure checks.

6 Troubleshooting

7 Maintenance Instructions

Recommended Maintenance Routines

Schedule of daily, weekly, and monthly checks for pump maintenance.

Oil Change Procedure

Instructions and oil specifications for performing pump oil changes.

Filter Replacement

Steps for replacing pump filter cartridges, specifying micron sizes.

7 Maintenance Instructions

Storage and Frost Protection

Guidelines for protecting the pump during storage or in freezing conditions.

Cleaning Guidelines

Recommended methods and agents to use for cleaning the pump.

Recycling and Disposal

Information on proper recycling and disposal of the product.

8 Technical Data

Specifications: Pumps Without Frequency Converter

Detailed technical specifications for pumps without frequency converters.

8 Technical Data

Specifications: Pumps With Frequency Converter

Detailed technical specifications for pumps equipped with frequency converters.

8 Technical Data

Dimensioned Sketch: Pumps Without Frequency Converter

Visual representation with dimensions of the pump without a frequency converter.

8 Technical Data

Dimensioned Sketch: Pumps With Frequency Converter

Visual representation with dimensions of the pump with a frequency converter.

Skov DA 2000 User Manual

Table of Contents

Questions and Answers:

Skov DA 2000 Specifications

Summary

1 Product Description

2 Product Survey

Product Accessories

Electronic Lime Decomposer

Chemical Filter with Non-Return Valve

Pump Accessories and Consumables

Phosphate Cartridge

External Filter Unit

Filter Cartridges and Oil

3 Mounting Guide

Water Supply Requirements

3 Mounting Guide

Recommended Tools

3 Mounting Guide

General Drawings and Principle Sketch

3 Mounting Guide

Pump with Frequency Converter Drawings

3 Mounting Guide

Pump Placement and Wall Mounting

3 Mounting Guide

Pre-Start Checks and Operation

3 Mounting Guide

Pump Accessories and Safety Valve

4 Installation Guide

Electrical Connection Safety

4 Installation Guide

Circuit Diagram: 1 x 230 V

4 Installation Guide

Detailed 1x230 Volt Wiring

4 Installation Guide

Circuit Diagram: 3 x 400 V

4 Installation Guide

Detailed 3x400 Volt Wiring

4 Installation Guide

Circuit Diagram: 3 x 220 V/3 x 230 V

4 Installation Guide

Detailed 3x230 Volt Wiring

4.3 Pump with Frequency Converter

Circuit Diagram: 3 x 230 V

4.3 Pump with Frequency Converter

Detailed 3x230 Volt Wiring

4.3 Pump with Frequency Converter

Circuit Diagram: 3 x 400 V

4.3 Pump with Frequency Converter

Detailed 3x400 Volt Wiring

4.4 Multi-Section Cooling Control

Relay Mounting in Climate Controllers

Climate Controller Setup and Testing

4.4 Multi-Section Cooling Control

System Wiring Diagram

5 Testing Procedures

System Checks

Complete System Test

6 Troubleshooting

7 Maintenance Instructions

Recommended Maintenance Routines

Oil Change Procedure

Filter Replacement

7 Maintenance Instructions

Storage and Frost Protection

Cleaning Guidelines

Recycling and Disposal

8 Technical Data

Specifications: Pumps Without Frequency Converter

8 Technical Data

Specifications: Pumps With Frequency Converter

8 Technical Data

Dimensioned Sketch: Pumps Without Frequency Converter

8 Technical Data

Dimensioned Sketch: Pumps With Frequency Converter