■
Daily Maintenance
SR3370 & SR2770 – 13184B Rev D page 9
Maintenance Information
❑ Pre-operational inspection
(Set the KEY SWITCH to off before starting this inspection).
COMPONENTS SERVICE REQUIRED
Fuel level Visually inspect
Fuel filter (diesel engines only) Visually inspect (condition)
Fuel leaks Visually inspect (hoses, connections, etc)
Engine Oil Check oil level (between dipstick lines)
Engine coolant Check fluid level and radiator hoses
Radiator cap Visually inspect (installation)
Platform entrance gate Visually inspect (installation, operation)
Wiring harness and connectors Visually inspect (installation, condition)
Battery terminals Visually inspect (installation)
Battery fluid level Visually inspect (covers plates)
Hydraulic oil reservoir cap Visually inspect (installation)
Hydraulic oil level Check fluid level (at line on side of tank)
Hydraulic oil leaks Visually inspect (hoses, tubes)
Tires and wheels
Visually inspect (condition)
Bolts and fasteners
Visually inspect (looseness)
Structural damage & welds Visually inspect (weld cracks, dents)
Platform guardrails Visually inspect (condition)
Lanyard anchor points (option) Visually inspect (condition)
Bubble level indicator Visually inspect (condition)
Guides, rollers and slides Visually inspect (condition)
Non slip tread grip Visually inspect (condition)
Wrist support Visually inspect (condition)
Operator manual Visually inspect (that the manual is in the holder)
Placards, decals and operators manual Visually inspect (installation and condition)
START THE ENGINE FROM THE BASE CONTROL PANEL TO CHECK THE FOLLOWING
Charging system Check condition (gauge)
Ground controls Actuate and visually inspect for proper operation
Emergency lowering (from the ground) Check operation (causes correct motion)
Platform controls Actuate and visually inspect for proper operation
Flashing light Check operation
Emergency lowering (from the platform) Check operation (causes correct motion)
Air Filter Check condition (gauge)
Safety prop Check operation
Parking brakes Check operation
Optional items Check operation
To Next Page
Loading...
