OPERATION
A Fuel filters are not blocked.
Note: Before starting a cold engine in cold
weather first cover the radiator with a radiator
cover. Remove the cover as soon as a normal
working temperature is achieved.
If the engine does not start regularly and easily,
do not continue as for you may run down the
battery. Bleed any air that may have accumulated
in the fuel system and, if the problem persists
check that:
B The battery and heater plugs are working
efficiently.
Breaking in
It is essential to take the following precautions
during the breaking in period:
C When breaking in, check regularly that all
screws, nuts and bolts are tight.
A During this period, do not subject the tractor
to loads greater than those it will have to
deal with during the rest of its working life.
Turning off the engine:
B Stop the engine by turning the starting key to
'OFF' position.
B Engage low gears when towing heavy
loads.
D To ensure prolonged clutch life, run in the
clutch discs correctly.
A Turn the engine accelerator to idle position.
{Temperature below 32° F (0 °C )}:
A Perform operations A to E as instructed above.
E Check that PTO lever is in neutral.
Battery:
B Check that the gear shifter lever is in neutral.
For Starting (normal weather conditions):-
C Move the low/ high speed selector lever to neutral
position.
A Engage the parking brake.
D Tractor is equipped with clutch safety switch, always
press the clutch pedal fully before starting the engine.
Cold Weather Starting
Proceed as Follows:
B Turn the starter key to 'heat' position and keep it there for
a few seconds and then turn the key to start position.
C If the engine fails to start repeat step 2, wait for further 5 to
10 seconds and then turn the key to start position again.
The battery should always be sufficiently charged. If the temp
goes below 14 Deg F (upto -10 deg C), it is
recommended to use below mentioned battery
specifications,
Note:
Ÿ 12V, More than 700 CCA (Length- 10.16 inch(258mm),
Width-6.78 inch(172mm), Height-8.86inch(225 mm)
A If the engine fails to start after two or three attempts and
smoke can be seen coming out of the exhaust, repeat
the starting procedure with less time glow plug heater.
IMPORTANT: When outdoor temperature
drops to around or below 32°F [0°C], check the
cooling system and if necessary add the
recommended antifreeze.
IMPORTANT: Do not inject fluids (ether) to
make the engine easier to start in cold weather.
The tractor is equipped with a cold start device.
When the engine is running, keep as a safe distance
from the radiator fan.
To prevent accidents, never allow anyone to sit on the
mudguards or on any other part of the tractor or
implement.
WARNING
WARNING
40-3
To Next Page
Loading...
