8-10
Lubrication and Servicing
AIR CONDITIONING RE-START PROCEDURE
If the machine has been idle for an extended period of time (2 weeks), the refrigerant in the air conditioning unit converts from a
gas to a liquid. This puts the compressor unit under a great deal of strain trying to compress a liquid instead of a gas and could
cause a failure in the air conditioning unit. The following commissioning procedure allows the air conditioning unit to achieve
normal operating parameters.
1. Start the machine and allow it to run until the engine is at a normal operating temperature of 80 °C (176 °F)
2. Turn the blower control to setting 1.
3. Turn on the air conditioning unit on for 5 seconds then off for 5 seconds.
4. Repeatedly switch the air conditioning on and off for at least 1 minute. This should be at least 12 repetitions.
5. Commissioning the air conditioning unit is complete and ready for use.
TYRE PRESSURES
Tyre pressures on this pages apply to the truck serial number range specified only, Gross Vehicle Weight (G.V.W.) and
axle weights may vary between truck derivatives. Tyre pressure should be recalculated if not shown for a particular truck.
Contact TEREX for assistance.
The tyre inflation pressures listed are manufacturers’ recommendations for G.V.W. travelling at maximum speed. TEREX
advise that operators check tyre inflation pressures with tyre manufactures to ensure correct setting for each particular
TYRE INFLATION PRESSURE
MODEL MANUFACTURE SIZE PATTERN FRONT REAR
BAR lb/in
2
BAR lb/in
2
TR35 BRIDGESTONE 18.00-R25 VMTP 7.4 108 7.7 111
877 BRIDGESTONE 18.00-R25 VMTS 7.4 108 7.7 111
MICHELIN 18.00-R25 XHD1-A4 6.2 90 6.2 90
ALTURA 18.00-R25 GRIPMASTER ND 7.0 102 7.0 102
ALTURA 18.00-R25 GRIPMASTER XL 7.0 102 7.0 102
TR45 BRIDGESTONE 21.00-R35 VMTP 7.7 111 7.2 105
881 BRIDGESTONE 21.00-R35 VELS 7.7 111 7.2 105
MICHELIN 21.00-R35 XDT-A4 5.5 80 5.2 75
BELSHINA 21.00-35 BEL51-A 5.8 84 5.8 84
TR60 BRIDGESTONE 24.00-R35 VMTP 6.5 94 6.3 91
882 BRIDGESTONE 24.00-R35 VRLS 6.5 94 6.3 91
MICHELIN 24.00-R35 XDT-A4 5.5 80 5.5 80
BELSHINA 24.00-35 FBEL-150 5.5 80 5.5 80
TR70 BRIDGESTONE 24.00-R35 VMTP 7.9 114 7.9 114
913 BRIDGESTONE 24.00-R35 VRLS 7.9 114 7.9 114
MICHELIN 24.00-R35 XDT-A4 7.2 105 6.9 100
TR100 BRIDGESTONE 27.00-R49 VMTP 7.0 102 6.8 98
783 BRIDGESTONE 27.00-R49 VRLS 7.0 102 6.8 98
MICHELIN 27.00-R49 XDT-A4 6.6 95 6.6 95
PACETRONIC 27.00-49 E4D 6.6 95 6.6 95
BELSHINA 27.00-49 FBEL-150 6.4 93 6.4 93
TR100DD BRIDGESTONE 27.00-R49 VMTP 7.0 102 6.8 98
883 BRIDGESTONE 27.00-R49 VRLS 7.0 102 6.8 98
MICHELIN 27.00-R49 XDT-A4 6.6 95 6.6 95
PACETRONIC 27.00-49 E4D 6.6 95 6.6 95