Home
Trane
Heater
UniTrane
Trane UniTrane Installation, Operation And Maintenance Instructions
4
of 1
of 1 rating
132 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
34
UN
T
-SVX07B-EN
Dimensions and W
eights
F
resh Air Opening Locations, V
ertical Unit
s—Models A, B
, F
, H, J
, K, L, M, and N
Fr
esh air opening dimension
s, vertical units
Unit Size
02–03
04
06
08
10–12
A
1’ 6”
1’ 11”
2’ 8-1/2”
3’ 5”
5’ 0”
B
1’ 9-5/16”
2’ 2-5/16”
2’
11-13/16”
3’ 8-5/16”
5’ 3-5/16”
33
35
Table of Contents
Default Chapter
4
Table of Contents
4
Model Number Descriptions
7
General Information
10
Pre-Installation
11
Receiving and Handling
11
Jobsite Storage
11
Installation Preparation
12
Service Access
12
Pre-Installation Checklist
13
Dimensions and Weights
14
Available Models
16
Factory-Installed Piping Packages
17
Vertical Concealed, Model a
18
Vertical Cabinet, Model B
19
Horizontal Concealed, Model C
20
Horizontal Cabinet, Model D
21
Horizontal Recessed, Model E
22
Vertical Wall Hung Cabinet, Model F (Force-Flo Units Only)
23
Vertical Recessed, Model H
24
Vertical Slope Top, Model J
25
Low Vertical Concealed, Model K
26
Low Vertical Cabinet, Model L
27
Inverted Vertical Cabinet, Model M (Force-Flo Units Only)
28
Inverted Vertical Recessed, Model N (Force-Flo Units Only)
29
Fan-Coil Coil Connections, Vertical Units
30
Fan-Coil Coil Connections, Horizontal Units
30
Force-Flo Coil Connections, Vertical Units
31
Force-Flo Coil Connections, Horizontal Units
31
Force-Flo Coil Connections, Inverted Units
32
Fresh Air Opening Locations, Horizontal Units-Models C, D, and E
33
Fresh Air Opening Locations, Vertical Units-Models A, B, F, H, J, K, L, M, and N
34
Wall Box
35
Projection Panel
36
Installation-Mechanical
37
Duct Connections
37
Piping Considerations
37
Installation-General
48
Installing the Unit
48
Vertical Units
48
Horizontal Units
48
Cabinet Units
49
Recessed Units
49
Installation Checklist
50
Installation-Controls
52
General Information
52
Control Options (Including Factory-Installed)
52
Installing Wall-Mounted Wired Sensors
53
Location Considerations
55
Fan Mode Switch Installation
55
Wired Zone Sensor Installation
55
Installing Wall-Mounted Wireless Zone Sensors
56
General Information
56
Product Description
56
Dimensions
56
Location Considerations
57
Mounting the Sensor Back Plate
57
Replacing the Sensor Cover
58
Installation-Electrical
59
Unit Wiring Diagrams
59
Supply Power Wiring
59
Electrical Grounding Restrictions
59
Wall-Mounted Control Interconnection Wiring
60
Controls Interface
67
Wired Controllers-Communication Wiring
67
Units with Tracer ZN510 and ZN520 Only
67
Device Addressing
67
Recommended Communication Wiring Practices
67
Wireless Temperature Sensor
68
Address Setting
68
Observing the Receiver for Readiness to Associate
69
Associating the Sensor to the Receiver
70
Testing Signal Strength and Battery Status
70
Configuring the Wireless Display Sensor (Model WDS Only)
71
Replacing the Sensor Cover
75
Sensor Operations
75
Wireless Sensor Specifications
78
Pre-Start
81
Pre-Startup Checklist
81
Start-Up
83
Tracer™ ZN510 & ZN520 Unit Startup
83
General Information
83
Fan Mode Switch Operation
84
Tracer ZN010 & ZN510 Operation
84
Tracer ZN520 Operation
85
Sequence of Operation: Tracer ZN010 and ZN510
86
Binary Inputs
86
Binary Outputs
87
Zone Sensors
88
Supply Fan Operation
88
Tracer ZN520 Sequence of Operation
89
Cooling Operation
91
Heating Operation
91
Fan Mode Operation
92
Space Temperature Measurement
98
Maintenance
101
Maintenance Procedures
101
Periodic Maintenance Checklists
105
Diagnostics
107
Troubleshooting
113
Troubleshooting the Relay (Daughter) Board
113
Troubleshooting Wireless Controls
115
Troubleshooting Tracer ZN010, ZN510, and ZN520
124
Manual Output Test
125
Wiring Diagrams
126
CSTI Fan Speed Switch
126
CSTI Non Fan Speed Switch
127
Line Voltage Fan Speed Switch
128
Tracer ZN010 with Electric Heat
129
Tracer ZN510 with Main and Auxiliary Valves
130
ZN520 with 2-Stage Electric Heat
131
Other manuals for Trane UniTrane
Installation, Operation And Maintenance
164 pages
Installation Operation & Maintenance
136 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Trane UniTrane and is the answer not in the manual?
Ask a question
Trane UniTrane Specifications
General
Brand
Trane
Model
UniTrane
Category
Heater
Language
English
Related product manuals
Trane UHSB
60 pages
Trane UniTrane FCD
64 pages
Trane UniTrane FCD 408
64 pages
Trane UniTrane FCD 721
64 pages
Trane FF
164 pages
Trane FCLB
164 pages
Trane BAYSPEK060
16 pages
Trane BAYHTRV108
12 pages
Trane BAYHTR1523BRKA
20 pages
Trane BAYHTR1517BRKA
20 pages
Trane BAYHTR1504BRKC
20 pages
Trane BAYHTFB318 Series
16 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General