Wacker Neuson ET65 - Page 282

8-4 BA E14 track en* 1.3 * E14t_13_800.fm
8 Troubleshooting
Malfunction/sign Possible cause Remedy See
Engine does not start or is not easy
to start
Empty fuel tank Refueling 7-31
Malfunctioning or empty battery Replace the battery --
Malfunctioning fuse Check the fuse 9-9
Engine starts, but does not run
smoothly or faultless
Air in fuel system Let the engine run 7-36
Water in fuel system Empty the water separator 7-36
Shortened DPF regenerations intervals
Frequent short starts Avoid frequent short starts
7-62
Polluted air filter
Observe Chapter Exhaust
Gas Treatment
Vehicle is being operated at
great heights
Regeneration deactivated or
interrupted
Perform regeneration
Incorrect engine oil
Observe the fuel, lubricants,
and coolants list
7-17
7-18
Wrong diesel fuel
Machine pulls to the right or left
Wrong track tension Tighten tracks correctly 7-55
Foreign bodies stuck in track Remove foreign bodies --
Uneven wear of the tracks
Contact a Wacker Neuson
service center
--
None of the hydraulic functions can
be operated
Control lever base raised
Fold down the control lever
base
4-54
Working light or horn does not work. Malfunctioning fuse
Check the fuse; Check the
plug connection at the work
light
9-9
Fan does not run
Malfunctioning fuse Check the fuse 9-9
Electrical fault
Contact a Wacker Neuson
service center
--
Reduced or no cooling capacity
Not enough refrigerant in the
system
Contact a Wacker Neuson
service center
--
Malfunctioning V-belt
Dirty condenser
Contact a Wacker Neuson
service center
--
Temperature controller set to
heating
Set the temperature control-
ler to cooling
5-16
Reduced heating output or none at all
Malfunctioning thermostat
Contact a Wacker Neuson
service center
--
Temperature controller set to
cooling
Set temperature controller to
heating
5-16
Loss of refrigerant
Loose hose connection
Contact a Wacker Neuson
service center
----
Leak in system
Very loud system
Malfunctioning V-belt
Contact a Wacker Neuson
service center
--
Damaged air conditioning com-
pressor
Damaged fan motor