© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
70457901ENR7
3
© Copyright 2013, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any
means without the expressed written consent of the publisher.
Table of
Contents
Introduction......................................................................................... 6
Model Identification ............................................................................. 6
Contact Information.............................................................................. 8
Safety Information.............................................................................. 9
Important Safety Instructions ............................................................... 10
Specifications and Dimensions........................................................... 12
Cabinet Dimensions.............................................................................. 13
Exhaust Outlet Locations...................................................................... 14
Gas Connection Locations.................................................................... 15
Electrical Connection Locations........................................................... 16
Steam Connection Locations ................................................................ 17
Installation........................................................................................... 18
Pre-Installation Inspection .................................................................... 18
Location Requirements......................................................................... 18
Position and Level the Tumble Dryer................................................... 20
Fire Suppression System....................................................................... 20
Check Local Codes and Permits ...................................................... 20
Water Requirements......................................................................... 20
Water Connections........................................................................... 21
Electrical Requirements ................................................................... 22
Auxiliary Alarm ............................................................................... 22
Bolt-On Angle Option .......................................................................... 23
To Reverse the Loading Door............................................................... 24
Before Placing Tumble Dryer into Service .......................................... 26
Required for CE Models Only ......................................................... 28
Installing CE Gas Drying Tumble Dryer.............................................. 28
General Information......................................................................... 28
CE Orifices....................................................................................... 29
Properties of CE Gases .................................................................... 29
Basic Configuration ......................................................................... 30
Specific Conversion Procedures ...................................................... 30
Exhaust Requirements ....................................................................... 32
Layout ................................................................................................... 32
Make-Up Air......................................................................................... 32
Venting ................................................................................................. 32
Individual Venting ........................................................................... 33
Manifold Venting............................................................................. 34
Gas Requirements............................................................................... 38
Gas Supply Pipe Sizing and Looping ................................................... 40
High Altitude Burner Orifice Sizing..................................................... 42
Electrical Requirements..................................................................... 43
Wiring Diagram .................................................................................... 43
Grounding Instructions ......................................................................... 44
For CE Models Only........................................................................ 44
Service/Ground Location ................................................................. 45
To Next Page
Loading...
Need help?
General