23
Care and preventive maintenance
The Sara Plus is subject to wear and tear, and the following actions must be performed when specified to ensure that the
product remains within its original manufacturing specification.
Preventive maintenance schedule
Action/Check
Between
patients
Before each
use
Every week Every
12 months
CAREGIVER OBLIGATIONS
Cleaning/Disinfection
X
Examine the sling, straps and clips for damage or fraying as required. Refer to sling
documentation.
XS
Visually check exposed surfaces for damage, sharp edges, etc.
X
Visually check sling attachment points. Do not use if damaged.
X
Make sure all labels are attached.
X
Check to make sure the hand grips are secure.
Re-bond if required.
XS
Examine the charger and wires for integrity and connections.
S
Operate the Sara Plus through its full range.
X
Visually check the handset and cable for damage.
X
Perform a full function test on the Sara Plus.
X S
Check operation of the Stop/Reset and System Lower Override Device.
XS
Check batteries for leakage and/or deterioration. Replace if required.
XS
Make sure all fixings, screws, nuts are secure and tight.
XS
Check and clean all castors. Replace as required.
XS
Check that the covers fit correctly and are not damaged. Replace as required.
XS
Check for evidence of corrosion. Replace as necessary.
XS
Warning: The points on this checklist are the minimum the manufacturer recommends. In some cases due to
heavy use of the product and exposure to aggressive environment, more frequent inspections shall be carried
out. Continuing to use this product without conducting regular inspections or when a fault is found will
seriously compromise the user and residents’ safety. Local regulations and standards may be higher than the
manufacturers. Preventive maintenance specified in this manual can prevent accidents.
Product cannot be maintained and serviced while in use with the patient.
Note:
Warning: The actions marked with ‘S’ must be carried out by qualified personnel, using correct tools and
knowledge of procedures referring to the Service Manual. Failure to meet these requirements could result in
personal injuries and/or unsafe product.
Warning: Unauthorized modifications or repairs to the Sara Plus may affect its safety and will invalidate
any warranty. Arjo accepts no liability for any incident, accident or reduction in performance that may
occur as a result of such repairs or modifications.
To maintain the safety of this equipment, always use only Arjo designated spare parts.
To Next Page
Loading...
