MD-6XP Mid-Rise Scissor Lift 25 P/N 5900108 — Rev. F — March 2020
Final Checklist Before Operation
Make sure these things have been done before using your Lift:
• Review the Installation Checklist to make sure all steps have been performed.
• Check the Hydraulic Fluid reservoir; it must be full of approved Hydraulic Fluid or automatic
transmission fluid.
You can harm the motor by running it without enough fluid.
• Check the Hydraulic System for leaks.
• Make sure that all Safety Locks are cleared and free.
• Leave the Manual with the Owner/Operator so that it is available for anyone who needs to read it.
Operation
This section describes how to operate your Automotive Lift.
⚠ DANGER When you even hear the words “Automotive Lift,” your brain should automatically
remember that lifting a Vehicle is a serious endeavor with life-threatening risks.
Focus on what you are doing. Automotive Lifts are dangerous tools when used by
inexperienced or impaired operators.
Do not assume you are going to be
safe this time because nothing happened last time
.
Safety Considerations
⚠ WARNING Your safety is dependent on reading, understanding, and implementing these
Safety Rules.
Do not skip over them—read them carefully and follow
them; your life could literally depend on it!
Do the following
before
you raise a Vehicle on your Lift, do the following each time:
• Check the Lift. Walk all the way around the Lift, checking for any missing, heavily worn, or
damaged parts. Do not operate the Lift if you find any issues; instead, take it out of service, then
contact your dealer, email support@bendpak.com
, or call (800) 253-2363.
• Check the area. Keep the area around and under the Lift clean and free of obstructions;
anything that could cause a problem. Do not forget to check
above
the Lift. If you find an
obstruction, move it out of the way.
• Check the operators. Make sure everyone who is going to operate the Lift has been trained in
its use, has read the labels on the unit, and has read the manual. Only the operator at the Controls
should be within 30 feet of the Lift while it is moving. Do not allow children to operate the Lift. Do
not allow anyone under the influence of drugs, alcohol, or medication to operate the Lift. Do not
allow any unauthorized personnel to operate the Lift.
• Check for safety. Make sure everyone who is going to be walking near the Lift is aware of its
presence and takes appropriate safety measures. Only put Vehicles on the Platform. When raising
a Vehicle, do not leave it until it is
engaged
on a Safety Lock. When lowering the Lift, do not leave
it until it is on the ground.
• Check the Vehicle. Never exceed the Lift’s weight rating. Do not allow people inside a Vehicle
you are going to raise. Make sure the Vehicle is not overbalanced on either end or either side.
To Next Page
Loading...
