MAINTENANCE CHART
FIRST
INSPECTION
10 hrs or
30days
or 300km (185
m.)
EVERY
SHOULD BE
DONE BY
I: Clean, Inspect, Verify, Adjust,
Lubricate, Replace if necessary
25 hrs or
750 km
(470m.)
50 hrs or
1500 km
(930m.)
100 hrs or
1 year
3000 km
(470m.)
200 hrs or
2 year
6000 km
(3730m.)
C: Clean
L: Lubricate
R: Replace
DRIVE TRAIN
Front (Gladiator only) / rear propeller
drive shaft
I L DEALER
Front (Gladiator only) / rear drive
shaft boots and protectors (pre-
operatoin inspection item)
I I USER
Wheel bearing I USER
Front (Gladiator only) / rear
differentail oil level, seals and vents
R I R DEALER
STEERING / CONTROL
Handlebar fasteners I DEALER
Throttle / housing / cable (pre-
operatoin inspection item)
I I USER
Steering system (more often under
severe use)
I I DEALER
Tie rod ends
I DEALER
Wheel nut / studs I I DEALER
Wear / pressure of tires (pre-
operatoin inspection item)
EVERY OPERATION USER
Front wheel alignment
I I DEALER
SUSPENSION
A arms (pre-operatoin inspection
item)
I I USER
Shock absorbers (pre-operatoin
inspection item)
I DEALER
BRAKE
Brake uid (pre-operatoin inspection
item)
I I R USER
Brake pads
I USER
Brake system (discs, hoses etc.)
(pre-operatoin inspection item)
I USER
BODY / FRAME
Engine compartment C C USER
Frame I DEALER
Hitch / tailer ball condition (if
installed)
I I USER
Chassis faterners
I USER
Seat latch (pre-operatoin inspection
item)
EVERY OPERATION USER
Vehicle cleaning and protection
C USER
To Next Page
Loading...
