Epson Stylus Photo R220 - Page 25

EPSON Stylus Photo R220/R230 Revision A
TROUBLESHOOTING Unit Level Troubleshooting 25
Table 1-13. Status and Possible Causes of Paper Out Error
Error Status
LED Indication
STM3 Message
Occurrence
Timing
Carriage Unit
Position
at Power-on
Faulty Unit/Part Name Possible Causes Remedy
Paper Out Error
Power : --
Paper : ON
Ink : --
Paper out or not
loaded correctly.
During
operation
-
ASF Assy.
The Compression Spring, 2.51 comes off.
Refer to
Table 1-14
The Extension Spring 0.45 comes off.
Holder, Shaft, LD Roller
The Extension Spring 0.143 comes off.
The projection of the Clutch is disconnected.
The Clutch Tooth is damaged.
The Clutch is damaged.
Frictional force of the LD Roller deteriorates.
The Paper Guide, Upper (HP Side) comes off.
PF Motor
The PF Motor Cable is disconnected.
PF Motor failure
The PF Motor Cable is damaged.
Ink System
The Compression Spring, 2.36 comes off.
The edge of the Lever, Change is damaged.
Table 1-14. Paper Out Error Check Points by Phenomenon
Occurrence Timing
Position of CR
Phenomenon Detail
Faulty Part/
Part Name
Check Point Remedy
During operation
-
THe Holder, Shaft, LD Roller rotates to
feed the paper, but the Hopper does not
operate.
ASF Assy.
1. Check if the Hopper works properly while feeding paper. 1. Reassemble the ASF Frame and the
Compression Spring, 2.51 correctly.
Compression Spring, 2.51