V10k automatic 2. Safety
5
EN
2. Safety
2.1 Intended use
The V10k chlorinator is the central item of a
disinfection system which doses chlorine gas
or sulphur dioxide gas into a flow of water. For
the use with carbon dioxide a separate instruc-
tion manual is available.
The V10k vacuum gas metering system must
be connected to a vacuum gas supply.
Action time is up to 100%.
Other use is prohibited without permission
from Evoqua.
The operational safety of the system can only
be guaranteed if it is used in accordance with
its intended purpose. It may only be used for
the purpose defined in the contract and under
the installation, operating and environmental
conditions stated in this operating manual. No
substances (chemicals) may be used other
than those described in this instruction
manual. All inspection and maintenance work
must be carried out at the prescribed inter-
vals.
Compliance with the intended use also inclu-
des reading this operating manual and obser-
ving all the instructions it contains.
The operator bears full and sole responsibility
if this unit is put to any use which does not
comply strictly and exclusively with this inten-
ded use.
Not intended use is especially
• use of other media (other gases)
• gas supply under pressure
2.2 General safety instructions
Evoqua Water Technologies GmbH attaches
great importance to the safety of all work rela-
ting to the system. This was already taken into
account in the design of the system, by the
integration of safety features.
The safety instructions in this documentation
must always be observed. These do not affect
the validity of any additional national or com-
pany safety instructions.
All safety instructions attached to the system
must be observed. They must always be com-
plete and easily legible.
The system has been constructed using the
best available technology and according to the
accepted safety regulations. However, danger
to the life and limbs of users or third parties or
damage to the system or other property can-
not be ruled out if the system, if the system is
used by unqualified persons. Installation and
maintenance, as well as any work that is not
described in this operating manual may only
be performed by authorized personnel.
Personnel
The operator of the overall system must
ensure that only authorized and qualified
technicians can work on or with the system,
and within their specified area of responsibi-
lity.
"Authorized and qualified personnel" include:
Operation and Maintenance leve 1
Personnel of the operator who have been trai-
ned and instructed by Evoqua or a service
partner.
Installation, Commissioning and Main‐
tenance level 2
Only Evoqua service personnel or personnel
who have been trained and authorized by Evo-
qua
Electrical work
Authorized and qualified electrical technicians
Spare parts/components
The trouble-free operation of the system can
only be guaranteed, if original spare parts and
components are used in the combination
described in this instruction manual. Other-
wise there is a danger of malfunction or
damage to the system.
Modifications and extensions
Never attempt to rebuild, modify or extend
the system without written approval from the
manufacturer!
Electrical power
Connect cables in accordance with the wiring
diagram. During normal operation, the posi-
tioner must remain closed. Switch off the
plant before starting mounting, inspection,
maintenance or repair, secure against swit-
ching-on.
To Next Page
Loading...
Need help?
General
