49
© Guldmann GB/US-02/2021 • # 550216_19
© Guldmann GB/US-02/2021 • # 550216_19
Caution: Take great care to ensure that no liquids get inside the lift. The lift is
not waterproof. Failure to protect the lift from liquids may result in damage to
the lift and/or may cause personal injury.
4.02 Storage
See 3.00
For long-therm storage, disconnect the battery plugs and the plug from the
battery at the charging PCB.
4.03 How to prevent/avoid corrosion?
When the products are mainly used in an corrosive environment, e.g. swim-
ming pool, the products must be ordered with a special corrosion-preventive
surface treatment. The preventive surface treatment must be replicated mini-
mum anually.
4.04 The owner’s daily maintenance duty
Check the lifting sling for wear and damage before use.
Do not use the lifting sling if it is damaged or defective.
Do not use the GH3 if the lifting strap is damaged or defective.
Contact your supplier and order a new lifting sling or a replacement of the
lifting strap. Replacement of the lifting strap must only be performed by
the Guldmann Service Team or by a qualied technician in accordance with
Guldmann’s instructions.
4.05 Disposal of the GH3 including batteries
Local and national regulations on environmentally correct recycling must be
observed.
Batteries (type NiMH) must always be delivered to an approved recycling
point.
5.00 Service and lifetime
5.01 Lifetime
The products have an expected lifetime of 15 years, on the condition of
correct use and correct service inspections, see section 5.02.
Estimated life time before change (status can be seen in the SIC program):
Lifting strap – 20.000 normal lift (85 kg/1000 mm)
Timing Belt – 20.000 normal lift (85 kg/1000 mm)
Battery – 20.000 normal lift (85 kg/1000 mm)
Replacement of components
Replacement of batteries, PCBs, load cells and lifting straps must be per-
formed by a qualied service technician or the Guldmann Service Team. Class
III scales must be veried by a Notied Body after servicing.
To Next Page
Loading...
