HER CHEE ATV-600 - Page 176

Ch. 15 FRONT BRAKE & FRONT WHEEL
15-3
Trouble Diagnosis
Soft brake lever
 Air inside the hydraulic system
 Hydraulic system leaking
 Worn master piston
 Worn brake pad
 Poor brake caliper
 Worn brake lining/disk
 Low brake fluid
 Blocked brake hose
 Warp/bent brake disk
 Bent brake lever
Uneven brake
 Dirty brake lining/disk
 Poor wheel alignment
 Clogged brake hose
 Deformed or warped brake disk
 Restricted brake hose and fittings
Brake noise
 Dirty lining
 Deformed brake disk
 Poor brake caliper installation
 Imbalance brake disk or wheel
Steers to one side
 Bent tie rods
 Wheel installed incorrectly
 Unequal tire pressure
 Incorrect wheel alignment
Steers to one side
 Bent tie rods
 Wheel installed incorrectly
 Unequal tire pressure
 Incorrect wheel alignment
Hard operation of brake lever
 Blocked brake system
 Poor brake caliper
 Blocked brake pipe
 Seized/worn master cylinder piston
 Bent brake lever
Tight brake
 Dirty brake lining/disk
 Poor wheel alignment
 Deformed or warped brake disk
Hard steering
 Faulty tire
 Insufficient tire pressure
Front wheel wobbling
 Faulty tire
 Worn front brake drum bearing
 Bent rim
 Axle nut not tightened properly