Periodic Maintenance Table of Contents
TABLE OF CONTENTS (Continued)
Gasoline Fuel Filter....................................................................................................................................... 50
Fuel Filter (Aisan LPG System), Replace .................................................................................................... 50
LPG Fuel Injector (Aisan Closed-Loop Low Emission System) .................................................................. 51
Integral Sideshift Carriage, Replace Bearings ............................................................................................ 51
Oxygen Sensor, GM 3.0L EPA Compliant Engine ....................................................................................... 51
Air Filter Element, GM 3.0L EPA Compliant Engine................................................................................. 51
Inspect Low Pressure Regulator (LPR) for Oil Buildup and Leaks............................................................ 51
Check Throttle Shaft for Sticking................................................................................................................. 52
Inspect Exhaust Manifold and Piping for Leaks .........................................................................................52
Test LPG/GAS Regulator Pressure............................................................................................................... 53
Safety Procedures When Working Near Mast.................................................................................................. 53
Hood Latch Check.............................................................................................................................................. 55
Lift Chain Adjustments ..................................................................................................................................... 55
Lift and Tilt System Leak Check ...................................................................................................................... 57
Lift Cylinder, Leak Check ............................................................................................................................. 57
Tilt Cylinder, Leak Check ............................................................................................................................. 58
Charging Battery ............................................................................................................................................... 58
Diesel Engine Fuel Injector Check.................................................................................................................... 58
Welding Repairs ................................................................................................................................................. 59
Overhead Guard Changes ................................................................................................................................. 59
Wheel and Tire Replacement ............................................................................................................................ 59
Solid Rubber Tire, Change S40-65XM Models............................................................................................. 59
Remove and Install Tire on Wheel ........................................................................................................... 60
Pneumatic Tire, Repair H45-65XM Models ................................................................................................. 61
Remove Wheels From Lift Truck.............................................................................................................. 61
Remove Wheel From Tire ......................................................................................................................... 61
Remove Tire From Two-Piece Wheel ................................................................................................... 62
Remove Tire From Three- and Four-Piece Wheels ............................................................................. 63
Install Wheel on Tire................................................................................................................................. 64
Install Tire on Three- or Four-Piece Wheels ....................................................................................... 64
Install Three-Piece or Four-Piece Wheel in Tire................................................................................. 64
Install Tire on Two-Piece Wheel........................................................................................................... 65
Install Two-Piece Wheel in Tire ........................................................................................................... 66
Add Air to Pneumatic Tires........................................................................................................................... 66
Wheels, Install........................................................................................................................................... 67
Dual Drive Wheels, Install ....................................................................................................................... 67
Solid Rubber Tire, Change H45-65XM Models ............................................................................................67
Remove Wheel From Tire ......................................................................................................................... 68
Install Wheel in Tire ................................................................................................................................. 69
Adhesives and Sealants..................................................................................................................................... 71
This section is for the following models:
S/H40-65XM [H177, D187]
iii
To Next Page
Loading...
