Jandy 200 User Manual

Page 2
ENGLISH
Jandy
®
Pro Series, JXi
™
Gas-Fired Pool & Spa Heater
|
Installation & Operation Manual
Table of Contents
Section 1. General Information ....................... 3
1.1 Introduction ......................................................... 3
1.2 Technical Assistance .......................................... 3
1.3 Consumer Information and Safety ...................... 3
1.4 Warranty ............................................................. 4
1.5 CerticationCodesandStandards ..................... 4
1.6 General Operation Description ........................... 4
1.7 Safety Controls ................................................... 4
Section 2. Installation Requirements .............. 5
2.1 Introduction ......................................................... 5
2.2 Materials Installer Must Provide ......................... 5
2.3 Specications ..................................................... 5
2.4 Heater Components ........................................... 6
2.5 Dimensions ......................................................... 7
2.6 Clearances ......................................................... 7
2.7 Field Assembly ................................................... 8
2.8 Location Requirements ..................................... 8
Section 3. Venting ..10
3.1 Combustion Air Supply ..................................... 10
3.2 Exhaust Venting ................................................11
3.3 Vent Pipe Sizing and Installation ......................11
Section 4. Gas Connections .......................... 15
4.1 Install Piping and Check Gas Supply ............... 15
4.2 Special Precautions for LP Gas........................ 16
Section 5. Water Connections ....................... 16
5.1 Water Piping Connections ................................ 16
5.2 Pump Sizing ..................................................... 17
5.3 Plumbing Connections ..................................... 18
5.4 Water Pressure Switch Adjustment .................. 19
5.5 Check Valve Installation ................................... 20
5.6 Reversing the Water Connections ................... 20
5.7 Pressure Relief Valve Installation ..................... 20
5.8 Auxiliary Components, Chlorinators,
Ozone Generators,
and Sanitizing Chemicals ................................. 21
Section 6. Electrical Connections ................. 21
6.1 General Information .......................................... 21
6.2 Service Access ................................................. 23
6.3 Main Power ...................................................... 23
6.4 Bonding ............................................................ 24
6.5 Optional Remote Controls ................................ 24
Section 7. Operating Instructions ................. 27
7.1 First-Time Start-Up Procedure ......................... 27
7.2 Starting the Heater ........................................... 27
7.3 Normal Operation ............................................. 28
7.4 Operating the Controller ................................... 28
7.5 Setting up Heater Options ................................ 29
7.6 Operating the Heater ........................................ 29
7.7 Temperature Set Point Lock ............................. 30
7.8 Shutting Down the Heater ............................... 30
Section 8. Maintenance .................................. 32
8.1 Winterizing ........................................................ 32
8.2 Spring Start-up ................................................. 32
8.3 Inspection and Service ..................................... 32
Section 9. Troubleshooting ........................... 33
9.1 Common Problems ........................................... 33
9.2 Service Diagnostic Messages .......................... 35
9.3 Ignition Control LED Service Codes ................. 35
Section 10. Professional Service
and Maintenance .......................... 36
10.1 Gas Pressure Offset Test ................................. 36
Section 11. Spare Parts ................................... 36
11.1 Ordering Information ........................................ 36
11.2 JXi Major Components ..................................... 37
11.3 Cabinet Assembly Spare Parts List
and Exploded Parts Diagram ........................... 38
11.4 Heat System Spare Parts List and
Exploded Parts Diagrams ................................. 39
11.5 Water System Spare Parts List and
Exploded Parts Diagrams ................................. 42
11.6 Electrical System Spare Parts List and
Exploded Parts Diagrams ................................. 43
Section 12. Water Chemistry .......................... 45

Jandy 200 Specifications

General

Brand	Jandy
Model	200
Category	Swimming Pool Heater
Language	English