20
Inspection Standard
Inspection is the first step to safety operation. Carry out daily inspection and
periodic inspection.
- Ensure that the operater refers to page 5 to 16 and carry out daily inspection.
- This chapter is composed of frequent and periodic inspection items (About each classification, refer to page 14).
- Inspection shall be performed by a competent person (with expertise), or consult with KITO.
- Inspection items are specified based on standard environment and conditions. Consult with KITO when using the Chain Hoist under special
environment or conditions.
- Periodic inspection needs disassembly/reassembly. Refer to the separate Disassembly/reassembly Manual for correct inspection.
Recommendation for Inspection
Only competent persons are allowed to inspect the chain hoist.
Anyone other than a competent person inspecting may result in death or severe injury.
Do not use parts beyond their discard limit or criteria and unauthorized parts for the KITO
Chain Hoist Model CX003/005.
Even if the part is an authorized part for KITO Chain Hoist, it may not be used for a different model.
Use parts correctly in accordance with the Disassembly/reassembly Manual.
Failure to do so may result in death or severe injury.
Do not perform inspection of a Chain Hoist subject to a load.
Before performing inspection of a Chain Hoist, place it on a floor.
Performing inspection of a Chain Hoist subject to a load may result in death or severe injury.
Perform inspection within a specified period.
Failure of inspection (frequent, periodic) causes death or severe injury.
Inspection may need to be performed earlier than inspection cycle depending on the condition of use. Inspect the hoist at
appropriate interval in consideration of the result of daily checks and operating noise.
If a defect is found while checking the chain hoist, stop using it, place a notice indicating
"failure/inspection underway" and request a competent person or KITO to carry out repair.
Use of a product with a defect may result in death or severe injury.
Prohibited
Prohibited
Mandatory
Mandatory
Mandatory
To Next Page
Loading...
Need help?
General
