6
Mounting
Before use
Before moving the load, warn all the surrounding people.
Failure to comply with these instructions may result in death or severe injury.
Mandatory
Check the following before using the chain hoist.
If a defect is found while checking the chain hoist, stop using it, place a notice indicating "failure/inspection in progress" and request
a competent person to carry out inspection and repair.
Failure to comply with these instructions may result in death or severe injury:
- Carry out daily inspection before operation (refer to page 15).
- Check to see whether there is any defect in the sling.
- Check to use a proper chain hoist for your purpose, capacity and lift.
- Check the work environment to see if the work area is secure to pull the hand chain vertically and to maintain a good view
without any obstacles to monitor the operation.
- Check to see if the footing is secure.
Mandatory
Safety precautions
Avoid the following when mounting the chain hoist.
Failure to comply with these instructions may result in death or severe injury:
- Ensure that only trained or competent persons install the chain hoist.
- Do not install the chain hoist within the range of movement of other devices (equipment), such as a trolley.
Comply with the following instructions when installing the chain
hoist.
Failure to comply with these instructions may result in death or severe injury:
- Check that the structure for mounting the chain hoist has sufficient strength.
- Fix the Top Hook to the structure securely.
- Before using the chain hoist with a trolley, read the Instruction Manual of the trolley carefully
and install it by adjusting the rail width.
- Install a stopper at both ends of the traversing rail for the trolley.
Prohibited
Mandatory
Stopper
Traversing rail
Trolley
Comply with the following instructions when installing the chain
hoist.
Failure to comply with these instructions may result in injury or damage to property:
- Install the chain hoist to avoid impeding the hoist.
- Install the Load Chain with sufficient length for lifting work.
- If the adjustment of the bottom of the hand chain between 500 mm and 1000 mm from the
ground is required, consult KITO.
Mandatory
Lift
To Next Page
Loading...
Need help?
General
