Mahindra 60 Series User Manual

93
60 Series 2WD/4WD, Model - 8560
Trouble Shooting
PROBABLE CAUSE POSSIBLE REMEDY
Air leak between compressor & intake manifold .......... Check and rectify.
Air leak between intake manifold & engine .................. Check and rectify.
Foreign object in exhaust manifold (from engine) ........ *
Restricted turbocharger oil drain line ............................ Check and rectify.
Turbocharger bearing housing sludged or coked .......... *
Excessive dirt build up on compressor wheel and/or .... *
diffuser vanes
Turbocharger bearing defective ...................................... *
Oil Leak From Compressor Seal
Restricted compressor intake duct ................................. Check and rectify. /*
Foreign object in exhaust manifold (from engine) ........ Check and rectify. /*
Restricted exhaust system ............................................... Check and rectify.
Restricted turbocharger oil drain line ............................ Check and rectify.
Turbocharger bearing housing sludged or coked .......... *
Excessive dirt build up on compressor wheel and/or .... *
diffuser vanes
Turbocharger bearing defective ...................................... *
Oil Leak From Turbine Seal
Restricted turbocharger oil drain line ............................ Check and rectify.
Turbocharger bearing housing sludged or coked .......... *
Excessive dirt build up on compressor wheel and/or .... *
diffuser vanes
Turbocharger bearing defective ...................................... *
Compressor / Turbine Wheel Defective
Turbocharger bearing defective ...................................... *
Foreign body damage on compressor or turbine .......... *
Insufficient oil supply to turbocharger........................... Check and rectify.
HYDRAULICS
No Lifting Or Slow Lifting
Less/no oil in system ....................................................... Check & fill oil to correct level.
Suction filter clogged ..................................................... Clean filter replace damaged.
Hydraulic pump has lost its efficiency ........................... Get the pump replaced.
Control valve defective ................................................... *
Control linkage defective ................................................ *
System overloaded .......................................................... Reduce load on system.
Hydraulic oil too cold ..................................................... Allow oil to warm.
Screen clogged ................................................................ Clean or replace screen.
Hydraulic Lift Arms Lifting Without Lever Operation
Control valve/linkage defects .......................................... *
System Overheating
Air in the system ............................................................ Locate the source of air entry and seal it.
Water in the system ....................................................... Drain oil & refill.
* See Mahindra Tractor Dealer

Mahindra 60 Series Specifications

General

Engine Power	60 HP
Cylinders	4
Steering	Power Steering
Fuel Type	Diesel
Transmission	8 Forward + 2 Reverse
Brakes	Oil Immersed
Gears	8 Forward + 2 Reverse
Engine Type	4-Stroke, Direct Injection