800-627-8569 15 Reel Disk from McFarlane Mfg.
Towing
General Safety
SAFETY
INSTRUCTIONS
Towing the Reel Disk requires care! Both the
unit and tow vehicle must be in good working
condition. Securely attach to towing unit. Use a
high strength, appropriately sized hitch pin with a
mechanical retainer and attach safety chain.
Make sure the hitch and coupling on the towing
vehicle are rated equal to, or greater than, the
unit’s “gross vehicle weight rating” (GVWR).
Refer to the specifi cation section.
Make sure the safety chain is securely fastened
to the tow vehicle.
Check the tires for tread wear, infl ation
pressure, and overall condition.
Inspect the hitch and coupling for wear or
damage. DO NOT tow the unit using a defective
hitch or coupling!
Make sure directional, brake, and running lights
are connected and working properly.
Make sure the lug nuts holding the wheels are
tight (torque to specifi cations) and that none
are missing.
When towing the unit on the highway, make
sure the “Slow Moving Vehicle” placard is
clearly visible.
Do not allow anyone to stand between the
tongue or hitch and the towing vehicle when
backing up to the equipment.
Make sure that the area is clear of children,
animals, and other obstacles before using.
Safety Chain
SAFETY
INSTRUCTIONS
• If the unit will be transported on a public highway, the
safety chain must be attached to the tow vehicle.
•
Always follow state and local regulations
regarding a safety chain when towing farm
equipment on a public highway.
• Be sure to check with local law enforcement
agencies for any local regulations or
restrictions.
• Do not use any device other than the safety chain
that was supplied with the unit. Only a safety chain
(not an elastic or nylon/plastic tow strap) should
be used to retain the connection between the tow
vehicle and the unit in the event of separation of the
primary attaching system.
Bystanders
SAFETY
INSTRUCTIONS
• Beware of physical surroundings and
especially bystanders, particularly children,
before moving the unit! This is particularly
important with higher noise levels and quiet
cabs, as you may not hear people shouting.
• NO PASSENGERS ALLOWED - Do
not carry passengers anywhere on or
in the tractor, except as required for
operation.
• Do not allow anyone to ride on the unit while it
is moving.
Towing and Maximum Towing Speed
SAFETY
INSTRUCTIONS
• Operate the towing vehicle from the operator’s seat
only.
• Do not exceed a towing speed of more than 20 mph
(0.5 KPH) on a public roadway.
• Remember, tires supplied by the manufacturer
are designed to operate LESS THAN 20 mph.
Do not exceed or tire failure may occur.
Highway and Transport Operations
SAFETY
INSTRUCTIONS
• Make sure the wheel cylinder transport locks are
installed, the wing lock pins are in place, and the jack
stand is in its storage position before transporting the
unit.
To Next Page
Loading...
