Section 1 - Warranty
90-864197076 NOVEMBER 2008 Page 13
What Is Not Covered
This limited warranty does not cover routine maintenance items, tune ups, adjustments, normal wear and tear, damage caused
by abuse, abnormal use, use of a propeller or gear ratio that does not allow the engine to run in its recommended wide‑open‑throttle
RPM range (see Specifications), operation of the product in a manner inconsistent with the recommended operation procedures,
neglect, accident, submersion, improper installation (proper installation specifications and techniques are set forth in the
installation instructions for the product), improper service, use of an accessory or part not manufactured or sold by us, jet pump
impellers and liners, operation with fuels, oils or lubricants which are not suitable for use with the product (see Specifications),
alteration or removal of parts, or water entering the engine through the fuel intake, air intake or exhaust system. Use of the product
for racing or other competitive activity, or operating with a racing type lower unit, at any point, even by a prior owner of the product,
voids the warranty.
Expenses related to haul‑out, launch, towing, storage, telephone, rental, inconvenience, slip fees, insurance coverage, loan
payments, loss of time, loss of income, or any other type of incidental or consequential damages are not covered by this warranty.
Also, expenses associated with the removal and/or replacement of boat partitions or material caused by boat design for access
to the product are not covered by this warranty.
Non‑warranty maintenance, replacement, or repair of emission control devices and systems may be performed by any marine
engine repair establishment or individual. The use of non‑Mercury parts for non‑warranty maintenance or repairs will not be
grounds for disallowing other warranty work. The use of add‑on (as defined at section 1900 (b)(1) and (b)(10) of Title 13 of the
California Code of Regulations) or modified parts not exempted by the California Air Resources Board may be grounds for
disallowing a warranty claim, at the discretion of Mercury Marine. Failures of warranted parts caused by the use of a non‑exempted
add‑on or modified part will not be covered.
Components Of The Emission Control System
1. Fuel Metering System
a. Carburetor and internal parts (and/or pressure regulator or fuel injection system)
b. Air/fuel ratio feedback and control system
c. Cold start enrichment system
d. Intake valve(s)
2. Air Induction System
a. Controlled hot air intake system
b. Intake manifold
c. Air filter
d. Turbocharger systems
e. Heat riser valve and assembly
3. Ignition System
a. Spark plugs
b. Magneto or electronic ignition system
c. Spark advance/retard system
d. Ignition coil and/or control module
e. Ignition wires
4. Lubrication System
a. Oil pump and internal parts
b. Oil injector(s)
c. Oil meter
5. Positive Crankcase Ventilation (PCV) System
a. PCV Valve
b. Oil filler cap
6. Exhaust System.
a. Exhaust manifold
b. Exhaust elbow
c. Intermediate exhaust elbow
d. Lower exhaust pipe
e. Tailpipe
7. Catalysts or Thermal Reactor System
a. Catalytic converter
To Next Page
Loading...
