SAFETY
PRECAUTIONS
It is.recommended that you read your engine manual and
become thoroughly acquainted with your equipment before
you start the engine.
WARNING
This
symbol
throughout this
is
used
manual to
warn of
possible
serious
personal injury.
CAUTION
This
symbol
refers
to
possible
equipment damage.
Fuels,
electrical equipment, batteries, exhaust gases and
moving parts present potential hazards that could result in
serious, personal injury. Take care in following these
recommended procedures.
Safety Codes
• All local, state and federal codes should be consulted
and complied
with.
General
• Provide appropriate fire extinguishers and install them
in convenient locations. Use an extinguisher rated ABC
by NFPA.
• Make sure that all fasteners on the engine are secure.
Tighten supports and clamps, keep guards in position
over fans, driving belts, etc.
• If it is necessary to make adjustments while the engine-
is running, use extreme caution when close to hot
exhausts, moving parts, etc.
Protect Against Moving Parts
• Do not wear loose clothing in the vicinity of moving
parts,
such as PTO shafts, flywheels, blowers;
couplings, fans, belts, etc.
• Keep your hands away from moving parts.
Batteries
• Before starting work on the engine,, disconnect
batteries to prevent inadvertent starting of the engine.
• DO NOT SMOKE while servicing batteries. Lead acid
batteries give off a highly explosive hydrogen gas which
can be ignited by flame, electrical arcing or by smoking.
• Verify battery polarity before connecting battery
cables. Connect negative cable last.
Fuel System
• DO NOT fill fuel tanks while engine is running, unless
tanks are outside engine compartment.
• DO NOT smoke or use an open flame in the vicinity of
the engine or fuel tank. Internal combustion engine
fuels are highly flammable.
• Fuel lines must be of steel piping, adequately secured,
and,free from leaks. Piping at the engine should be
approved flexible line. Do not use copper piping on
flexible lines as copper will work harden and become
brittle enough to break.
• Be sure all fuel supplies have a positive shutoff valve.
Exhaust System
• Exhaust products of any internal combustion engine
are toxic and can cause injury,'or death if inhaled. All
engine installations, especially those within a confine,
. should be equipped with an exhaust system to dis-
charge gases to the atmosphere.
• Do not use exhaust gases to heat a compartment.
• Make sure that your exhaust system is free of leaks.
Ensure that exhaust manifolds are secure and are not
warped by bolts unevenly torqued.
Engine Exhaust Gas (Carbon Monoxide) is Deadly!
Carbon monoxide is an odorless, colorless gas formed by
incomplete combustion of hydrocarbon fuels. Carbon
monoxide is a dangerous gas that can cause un-
consciousness and is potentially lethal. Some of the
symptoms or signs of carbon monoxide inhalation are:
• Dizziness • Vomiting
• Intense Headache • Muscular Twitching
• Weakness and Sleepiness • Throbbing in Temples
If you experience any of the above symptoms, get out into
fresh air immediately.
The best protection against carbon monoxide inhalation is
a regular inspection of the complete exhaust system. If you
notice a. change in the sound or appearance of exhaust
system,
shut-the unit down immediately and have it
inspected and'repaired at once by a competent mechanic.
Cooling System
• - Coolants under pressure have a higher boiling point
than water. DQ NOT open a radiator pressure cap while
the engine is running. Bleed the system pressure first.
Keep the Unit and Surrounding Area Clean
• Make sure that oily rags are not left on or near the
engine.
• Remove all oil deposits. Remove all unnecessary grease
and oil from the unit. Accumulated grease and oil can
cause overheating and subsequent engine damageand
may present a potential fire hazard.
To Next Page
Loading...
Need help?
General
