PERIODIC SERVICE
MAINTENANCE TIME TABLE
Initial maintenace General maintenance
period
Items
Contents
10 hours
（1 month）
50 hours
（3 months）
100 hours
（6 months）
200 hours
（1 year）
Anode
Inspection/replacement
○ ○
Spark plug
Cleaning/adjustment
/replacement
○ ○ ○
Grease points
Greasing
○
Bolts and nuts
Inspection
○ ○
Fuel tank and fuel line
Inspection
○
Fuel filter
Inspection/replacement
○ ○ ○
Fuel cock
Inspection/replacement
○ ○
Carburetor
Inspection/replacement
○ ○
Throttle cable
Inspection/replacement
○ ○
Idling speed
Inspection/ adjustment
○ ○
Start-in-gear projection Inspection/ adjustment
○ ○
Engine oil
Replacement
○ ○
Valve cleanrance
Inspection/ adjustment
○ ○
Ignition timing
Inspection
○ ○
T.C.I air gap
Inspection/ adjustment
○ ○
Thermostat
Inspection
○
Cooling water passage
Inspection/Cleaning
○ ○
Gear oil
Replacement
○ ○
Water pump
Inspection
○
Propeller
Inspection/replacement
○ ○
CAUTION:
After running the outboard engine in salt water, waste water or mud water, wash
over the engine by fresh water immediately.
If using leaded gasoline frequently, check the valve and components each 100 hours.
FUEL SYSTEM
1. CHECK FUEL TANK, CARBURETOR, FUEL PUMP AND FUEL PIPE
Check if fuel tank, carburetor, fuel pump and fuel pipe are damaged or leaked.
Replace if necessary.
Check if the fuel filter on the tank is dirty. Clean dirt or replace it if necessary.
13
https://www.boat-manuals.com/
To Next Page
Loading...
Need help?
General
