Piper PA-28RT-201T - Page 27

5-20-01
Page 5-04
Revised: July 13, 1983
PERIODIC INSPECTIONS. (cont)
—NOTE—
Perform all inspections or operations at each of the inspection
intervals as indicated by a circle (O). (See Notes 1, 2 and 3.)
B. ENGINE GROUP (CONTINENTAL) (cont)
32. Overhaul or replace pressure pump (See Note 7)
33. Inspect throttle, alternate air, mixture and propeller governor
controls for travel and operating condition ........................................ O O O
34. Inspect exhaust stacks, connections and gaskets (Replace gaskets as
required).............................................................................................. O O O O
35. Inspect breather tubes for obstructions and security .......................... O O O
36. Inspect crankcase for cracks, leaks and security of seam bolts .......... O O O
37. Inspect engine mounts for cracks and loose mountings...................... O O O
38. Inspect rubber engine mount bushings for deterioration (Replace as
required).............................................................................................. O O O
39. Inspect all engine baffles and seals..................................................... O O O
40. Inspect fire wall seals.......................................................................... O O O
41. Inspect condition of alternator and starter........................................... O O O
42. Inspect all lines, air ducts, electrical leads and engine attachments
for security, proper routing, chafing, cracks, deterioration and
correct installation (See latest revision of Piper Service Bulletin 561) O O O O
43. Check air conditioning compressor oil level (See Note 15)
44. Inspect condition and tension of compressor drive belt...................... O O O
45. Inspect security of compressor mounting........................................... O O O
46. Inspect compressor clutch security and condition of wiring
(See Note 16) ...................................................................................... O O O
47. Check fluid in brake reservoir (fill as required).................................. O O O O
48. Overhaul or replace propeller governor (Refer to latest
revision of Hartzell Service Letter No. 61)
49. Complete overhaul of engine or replace with factory rebuilt
(See Note 7)
C. TURBOCHARGER GROUP (CONTINENTAL)
1. Inspect all air inlet ducting and compressor discharge ducting for
worn spots, loose clamps or leaks....................................................... O O O O
2. Inspect engine air inlet assembly for cracks, loose clamps and screws O O O O
3. Inspect exhaust ducting and exhaust stacks for signs of leaks or
cracks. Check all clamps for tightness................................................ O O O O
4. Inspect exhaust heat exchanger........................................................... O O O
5. Carefully check all turbo support brackets, struts, etc., for
breakage, sagging or wear................................................................... O O O O
1B3
PIPER AIRCRAFT
PA-28RT-201 / 201T
MAINTENANCE MANUAL
Inspection Time (hrs)
50 100 500 1000
Nature of Inspection