PORTABLE ELECTRIC VOLTstack 5k - Table of Contents

TABLE OF CONTENTS
INTRODUCTION 3
SAFETY OVERVIEW 5
Safety Instruction Convention 5
Operational Tips and Instruction
Convention
5
TABLE OF CONTENTS 6
TERMINOLOGY 7
VOLTstack Power Modes 7
VOLTstack Power States 7
Amp Hour (Ah) 7
Battery Management System (BMS) 7
Battery Pack 7
Face Plate 7
KiloWatt Hour (kWh) 7
Net Power 8
Rear Plate 8
Run Time 8
State of Charge 8
SUNstack Solar Kit 8
Surge 8
VOLTstack Power Block 8
VOLTSTACK SAFETY 9
Safety Label Locations 9
Important Safety Information 9
Operator Responsibility 9
Environmental Considerations 10
Paralleling Outputs 10
Electrical Arcing 11
Grounding 11
Floating Neutral 11
Connecting to Grid 12
COMPONENT IDENTIFICATION
AND LOCATION
13
Exterior 13
Face Plate 14
Rear Plate 14
Interior 15
Serial Number 15
GETTING STARTED 16
Pre-Operation Check 16
Recharging 16
Turning Power On 16
Turning Power O 16
OPERATION 17
Applications 17
Battery Storage Capacity 18
Battery Monitor State of Charge 18
Battery Monitor Operation 19
Type 1 Battery Monitor 19
Discharging 19
Charging 19
State or Charge Low 19
Fault Warning 19
Connection Error 19
Standby Operation 19
Power ON Operation 20
Low State of Charge Cut-o 20
Load vs Run Time 20
AC Charging Operation 20
Solar Charging Operation 21
Important Safety Information 21
Getting Started 22
Charging Complete 22
Power On While Charging 23
USB 5V Charging 24
Self Consumption 24
Controller Settings 24
DC Operating Fuse Replacement 24
Hot and Cold Temperature Operation 24
High Temperature AC Output 25
High Temperature AC Charging 25
High Temperature Shut-Down 25
Cold Temperature AC Output 25
Cold Temperature AC Charging 25
MAINTENANCE 26
Maintenance Schedule 26
Opening the Lid 28
Caster Maintenance 28
Air Intake Filter Maintenance 29
Environmental Fan Maintenance 30
Interior and Power Block Maintenance 31
Connection Points Maintenance 31
Battery System Maintenance 31
Replacement Parts 32
STORAGE 33
Storage Environment 33
Storage Procedure 33
Storage Precautions 33
VOLTstack Health in Storage 34
TRANSPORTATION 35
Transportation Preparation 35
Ground Transportation 35
Transportation by Air 35
TROUBLESHOOTING 36
TECHNICAL INFO 37
5k Wiring Diagram 37
AC Terminal Strip Wiring 38
Device Power Ratings 39
Spec Sheet 40
Dimension Sheet 41
Version 1.0 September 2019
6