Sea-doo 2004 3D RFI User Manual

Engine Will Not Start
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Safety lanyard removed.
Install cap over post.
Burnt fuse on MPEM: battery,
or main fuse.
Check wiring then replace
fuse(s).
Discharged battery.
RefertoanauthorizedSea-Doo
dealer.
Battery connections, corroded
or loose.
RefertoanauthorizedSea-Doo
dealer.
Water-flooded engine.
Refer to WATER-FLOODED
ENGINE in SPECIAL
PROCEDURES.
Faulty sensor or MPEM.
Seized engine.
RefertoanauthorizedSea-Doo
dealer.
Engine does not turn over.
Seized jet pump. Try to clean. Otherwise, refer
to an authorized Sea-Doo
dealer.
Loose battery cable
connections.
Check/clean/tighten.
Discharged or weak battery.
Engine turns slowly.
Worn starter.
RefertoanauthorizedSea-Doo
dealer.
Fuel tank empty or
water-contaminated.
Refill. Siphon and fill with fresh
fuel.
Fuel filter clogged.
Clean, check fuel tank for
water.
Fouled/defective spark plugs. Replace.
Fuel-flooded engine.
Refer to FUEL-FLOODED
ENGINE in SPECIAL
PROCEDURES.
Faulty component in the fuel
injection system.
RefertoanauthorizedSea-Doo
dealer.
Burnt fuel pump fuse.
Check wiring then replace fuse.
Engine turns normally.
Electrical problem.
RefertoanauthorizedSea-Doo
dealer.
Engine Misfires, Misinjects, Runs Irregularly
OTHER OBSERVATION POSSIBLE CAUSE REMEDY
Fouled/defective/worn spark
plugs.
Replace.
Faulty MPEM.
RefertoanauthorizedSea-Doo
dealer.
Weak spark.
Too much oil supplied to engine. Improper oil pump adjustment,
refer to an authorized Sea-Doo
dealer.
94
______________________
www.SeaDooManuals.net

Sea-doo 2004 3D RFI Specifications

General

Brand	Sea-doo
Model	2004 3D RFI
Category	Boat
Language	English