Siemens KG39EAI43 - Checking Dryer Capsule; Installing Reducing Connector; Connecting Capillary Tube; Connecting Dryer and Capillary Tube

73 pages

To Next Page

To Previous Page

8.1.8 Checking dryer capsule

Video tutorial

8.1.9 Installing reducing connector

Video tutorial

8.1.10 Connecting capillary tube

Video tutorial

8.1.11 Connecting dryer and capillary tube

Video tutorial

Repair

2020-08-03_58300000002379_ara_en_p Copyright by BSH Hausgeräte GmbH Page56of73

Main Page

Table of Contents1
Concerning this Document4
Important Information4
Purpose4
Target Group4
Other Applicable Documents4
Explanation of Symbols4
Danger Levels4
Hazard Symbols4
Structure of the Warnings5
General Symbols5
Safety6
Qualification6
General Safety Instructions6
All Domestic Appliances6
Product-Specific Safety Information7
Refrigeration and Freezer Appliances7
Measures after each Repair7
Design and Function8
Energy Label8
Energy Label: Valid until February 28, 20218
The New Energy Label: Valid from March 1, 20218
Cooling Zones10
Speed Controlled Compressor11
Dryer12
Hinges13
Concealed (Cap) Hinge13
Flat Hinge13
Cushioned Flat Hinge13
Sliding (Tandem) Hinge14
Hinge for Flush Door (Fat Hinge)14
Lokring Connections15
Winter Switch17
Iservice Functions18
Iservice Overview18
Tools and Aids21
Refrigeration Circuit Repair Tools21
Water Circuit Repair Tools23
Repair Support Tools and Aids23
Measuring Tools25
Cleaning and Care Accessories26
Fault Diagnosis27
Condensation / Humidity / Leakage27
Moisture on Food or Glass Plates27
Compressor Evaporation Tray Overflowing27
Compressor27
Compressor too Hot27
No Cooling Power28
Protective Conductor Connection on Compressor Detached28
Filling Pipe on Compressor too Short28
Mechanical Damage29
Stainless Steel Rusts29
Stainless Steel Discoloured29
Crack at Bottom of Refrigerator Compartment in Front of Vegetable Drawer30
Horizontal Stress Crack on the Back Wall above or below the Foamed-In Evap- Orator31
Vertical Crack on the Back Wall Originating from the Fan32
Cracks in Cabinet Cover32
Bitumen Mass Dissolves33
Small Holes in Refrigerator Compartemnt Cooler Innerliner33
Circle Stains on Glass Shelves34
Refrigeration Circuit Pipe Is Pressed34
Installation Fault35
Increased Power Consumption and Cooling Power Affected35
Appliance Protruding35
Front Panel Hits against Body, Door Does Not Close35
Front Panel Brushes against Kitchen Cabinets35
Top Cabinet Cover Brushes against Front Panel35
Screw Brushes against Cover Mask35
Cabinet Base Softens, Appliance Lifts up or Sinks35
Noise35
Compressor Noise35
Clicking Sounds36
Swishing Noises36
Vibration Noises36
Injection Noises on the Evaporator37
Abnormal Noises37
Odour39
Typical Plastic Smell39
Strong Smell of Food39
Off-Odors Coming from the Appliance Exterior40
Result Problem41
Drinking Water Tastes Stale41
Temperature Problem41
Complete over Icing of the Evaporator41
Icing up / Condensation on Side Panels42
Build-Up of Ice at a Single Point42
Icing up on Input of Evaporator43
Frost on Dryer44
Frost on Suction Pipe45
Icing up on No-Frost Evaporator45
Measuring Technology46
Measuring Temperature Inside the Appliance46
Temperature Measurement with Data Logger46
Nominal Temperature Graph48
Checking Temperature Indicator (Sticker "OK")49
Measuring Energy Consumption49
Test50
Performing Customer Service Test Program50
Tracing Leakage in Refrigeration Circuit51
Checking Compressor (Quick Test)52
Checking Compressor Input Current52
Checking Speed on the Inverter Module52
Checking Resistance Values of Compressor Motor Windings52
Checking Stop Valve53
Checking Stop Valve for Leaks53
Checking Stop Valve Function53
Measuring Stop Valve Power Consumption53
Measuring Suction Pressure53
Repair54
Inside Lokring Technology54
Hints for Lokring Installation54
Using Lokring Pliers54
Handling Lokring Pliers with Two Pivots54
Changing Lokring Pliers Jaw55
Selecting Correct Lokring55
Using Lokprep55
Using Capillary Tube Pliers55
Checking Dryer Capsule56
Installing Reducing Connector56
Connecting Capillary Tube56
Connecting Dryer and Capillary Tube56
Connecting Aluminium and Copper Pipes57
Making One-Sided Pressed Connection57
Installing NTR Connection (Y-Pipe) (Part 1)57
Installing NTR Connection (Y-Pipe) (Part 2)57
Connecting T-Piece with Schrader Valve58
Repairing too Short Compressor Tube58
Rinsing Refrigeration Circuit59
Repairing Refrigeration Circuit (R600A)60
Replacing Dryer and Compressor60
Disposing Compressor Oil61
Preparing Refrigerant (R600A)61
Evacuating Refrigeration Circuit (R600A)61
Filling Refrigeration Circuit (R600A)63
Repairing Refrigeration Circuit (R134A)64
Replacing Dryer and Compressor64
Disposing Compressor Oil65
Filling the Filler Cylinder (R134A)65
Evacuating Refrigeration Circuit (R134A)66
Filling Refrigeration Circuit (R134A)67
Sanitising the Water System68
Sticking Brand Logo69
Customer Advice71
Reducing Energy Consumption71
Room Conditions71
Compartment Temperatures71
Door Opening Times71
Food Storage72
Defrosting72
Transporting the Appliance73

Siemens KG39EAI43 - Checking Dryer Capsule; Installing Reducing Connector; Connecting Capillary Tube; Connecting Dryer and Capillary Tube

Table of Contents

Related product manuals