Terex TA300 - TA300 Service Lubrication Chart

Safety
2-28
TA300 Service Lubrication Chart
NOTES ON LUBRICATION AND SERVICE CHART
NOTE 1 - CAPACITIES GIVEN ARE APPROXIMATE - WORK TO DIPSTICK, SIGHT GAUGES OR LEVEL PLUGS.
NOTE 2 - CAPACITY OF FRONT AND REAR DIFFERENTIALS 21 LTR (5.5 US GAL)
CAPACITY OF CENTRE DIFFERENTIAL IS 23 LTR (6 US GAL)
NOTE 3 - LUBRICATE SLOWLY UNTIL EXCESS LUBE IS SEEN.
NOTE 4 - REMOVE PLUG FROM PORT ON UNDERSIDE OF OSCILLATION HUB. PLUG IS REMOVED TO DRAIN THE CAVITY OF ANY OIL THAT
ENTERS THE CAVITY WHEN FILLING. REMOVE THE COVER PLATE AND LEVEL PLUG ON SIDE OF OSCILLATION HUB. ADD OIL
IF REQUIRED. REFIT ALL PLUGS.
EO - ENGINE OIL. REFER TO "RECOMMENDED LUBRICANTS".
HO - HYDRUALIC OIL. REFER TO "RECOMMENDED LURICANTS".
EPL - EXTREME PRESSURE GEAR LUBRICANT. REFER TO "RECOMENDED LUBRICANTS".
EP,NLGI - EXTREME PRESSURE LITHIUM No. 2 GREASE (WITHOUT "MOLY").
PAG OIL - POLYALKLENE GLYCOL (PAG) COMPRESSOR LUBRICATING OIL - LOW VISCOSITY (ISO46)
LUBRICATION AND SERVICE CHART
INTERVAL
HOURS
NO.
PTS
REF
PTS
SERVICE INSTRUCTIONS SERVICE QUANTITIES
LUBRICANT
OR COOLER
IDENTIFICATION
10
DAILY
50
WEEKLY
250
MONTHLY
1
1
2
3
3
4
7
24
1
1
1
1
1
1
6
EO
-
EO
HO
-
ETHYLENE
GLYCOL
-
-
EP, NLGI
EP, NLGI
EP, NLGI
EP, NLGI
EP, NLGI
-
-
EP, NLGI
AS REQUIRED
AS REQUIRED
AS REQUIRED
SEC 160- 0050
ENGINE
ENGINE
TRANSMISSION
HYDRAULIC TANK
HYD. FILTER RESTRICTION GAUGE
RADIATOR EXPANSION TANK
ENGINE AIR CLEANER
TYRES
CHECK OIL LEVEL. ADD OIL IF LOW
CHECK FOR LEAKS
CHECK OIL LEVEL. ADD OIL IF LOW
CHECK OIL LEVEL. ADD IF LOW
CHECK. RENEW ELEMENT IF REQ'D
CHECK COOLANT LEVEL. ADD IF LOW
CHECK. RENEW ELEMENT IF REQ'D
CHECK CONDITION & PRESSURE
19
20
21
25
27
35
6
3
1
2
2
2
EPL
EPL
-
EP, NLGI
-
EP,NLGI
AS REQUIRED
AS REQUIRED
-
SEE NOTE 3
-
-
SEE NOTE 3
WHEEL PLANETARIES
DIFFERENTIALS
OSCILLATION PIVOT
ARTICULATION BEARINGS
PARKING BRAKE PADS
FRONT AXLE (IFS)
CHECK OIL LEVEL. ADD IF LOW
CHECK OIL LEVEL. ADD IF LOW
CHECK END FLOAT. ADJUST IF REQ'D
LUBE
CHECK WEAR. RENEW IF REQ'D
LUBE
9
12
10
11
13
15
30
14
2
2
4
4
2
72
1
4
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
SEE NOTE 3
600 Nm / 442 lbf ft
SEE NOTE 3
OSCILLATION BUSHES
SUSPENSION BEAM BUSHINGS
STEERING CYLINDER PINS
BODY CYLINDER PINS
BODY HINGE /TAILGATE PINS
WHEEL RIM NUTS
CAB FRESH AIR FILTER
PANHARD ROD BEARINGS
LUBE
LUBE
LUBE
LUBE
LUBE
CHECK TORQUE
INSPECT & CLEAN IF REQUIRED
LUBE
15362898
500
3 MONTH
1
16
17
8
1
1
1
2
EO
-
-
-
-
-
-
AS REQUIRED
ENGINE
ENGINE OIL FILTER
CENTRIFUGAL OIL FILTER
BATTERY ELECTROLYTE
DRAIN OIL & REFILL WITH NEW OIL
RENEW
CLEAN
CHECK LEVEL, ADD ELECTRO IF LOW
4000
6000
33 1PAG OIL-AIR CON. COPRESSOR DRAIN, FLUSH & REFILL WITH NEW
REFRIGERANT OIL
5 ---COOLING SYSTEM DRAIN, FLUSH & REFILL WITH NEW
COOLANT
1000
6 MONTH
2000
ANNUALLY
2
2
3
6
2
28
29
22
30
32
8
18
26
1
1
1
3
1
2
1
1
1
1
2
1
1
EO
-
-
-
-
-
-
EPL
-
-
-
-
-
-
REF. SERVICE MANUAL
-
-
-
-
-
SEE NOTE 4
-
-
-
-
-
TRANSMISSION
TRANSMISSION
HYDRAULIC TANK BREATHER
FUEL FILTER / WATER SEPARATOR
TRANSMISSION BREATHER
TRANSMISSION OIL FILTERS
TRANSMISSION INTERNAL
STRAINER
DRIVESHAFT BEARINGS
CAB FRESH AIR FILTER
FUEL TANK
BATTERIES
DRIVE BELT
ADBLUE TANK
DRAIN OIL & REFILL WITH NEW OIL
RUN AEB STARTER
RENEW
RENEW
CLEAN IF REQUIRED
RENEW
CLEAN
CHECK OIL LEVEL. ADD IF LOW
RENEW
RENEW CAP FILTER / CATRIDGE
CLEAN, CHECK STATE OF CHARGE
CHECK FOR DAMAGE
RENEW REDUCTANT FILTER
3
19
19
20
25
31
4
23
1
2
7
1
34
1
6
6
3
1
1
1
5
4
3
1
20
24
HO
-
EPL
EPL
-
-
-
-
-
-
-
-
-
-
REF. SERVICE MANUAL
-
SEE NOTE 2
1425 Nm / 1050 lbf ft
-
-
-
200 Nm / 148 lbf ft
920 Nm / 679 lbf ft
-
-
671 Nm / 495 lbf ft
HYDRAULIC TANK
BRAKE PACKS
WHEEL PLANETARIES
DIFFERENTIALS
ARTICULATION PIVOT NUT
HYDRAULIC OIL FILTER
RADIATOR EXPANSION TANK
DRIVELINES
ENGINE MOUNTING BOLTS
TRANSMISSION MOUNTING BOLTS
ENGINE AIR CLEANER
ENGINE
AXLE MOUNTING BOLTS
DRAIN OIL & REFILL WITH NEW OIL
CHECK BRAKE WEAR
DRAIN OIL & REFILL WITH NEW OIL
DRAIN OIL & REFILL WITH NEW OIL
CHECK TORQUE
RENEW
CHECK COOLANT ANTIFREEZE
CHECK FOR DAMAGE
CHECK TORQUE
CHECK TORQUE
CLEAN/RENEW FILTER ELEMENT
CHECK AND ADJUST VALVE
CLEARANCE
CHECK TORQUE
33
8
6
7
29
2
28
35
10
11
9
21
19
23
12
15
34
14
24
13
20
27
22
25
31
30
32
18
16
1
5
26
17
4
3
MOT00135