Toyota 8FGCU25 Repair Manual

8-1838 TROUBLESHOOTING
Control type
Phenomenon on
vehicle
Malfunction area
and mode
Checking method Corrective action
OPS
Cowl lever, mini
lever, joystick lever
vehicles:
No material handling
can be performed.
▪ Seat switch unit:
Open fault (in-
ternal damage)
▪ Seat switch line
(Signal, ground):
Disconnection
fault (Harness,
connector)
ON/OFF check with
analyzer
Harness check or re-
place switch
▪ C/V unload
valve:
Stuck (internal
damage)
For cowl lever
vehicles:
Turn the unload
valve solenoid OFF
and perform lift rais-
ing operation using
an active test.
For mini lever, joy-
stick lever vehicles:
Turn the unload
valve solenoid ON
and perform lift rais-
ing operation using
an active test.
If raising cannot be
performed, replace
the C/V unload
valve.
▪ SAS/OPS con-
troller, OPS con-
troller:
Controller defect
- Replace
8

Toyota 8FGCU25 Specifications

General

Load Capacity	5000 lbs
Lift Height	189 inches
Power Source	Internal Combustion
Fuel Type	Gasoline/LPG
Operator Type	Seated
Lift Speed (loaded/unloaded)	122 fpm
Lowering Speed (loaded/unloaded)	98 fpm / 98 fpm
Mast Height (lowered/raised)	83 inches
Weight	3, 500 kg