Trane RTHD series User Manual

RTHD-SVX02H-EN 3
Contents
Warnings, Cautions and Notices ......................2
General Information ..........................................7
Unit Identification - Nameplates .................... 7
Figure 1. Typical Unit Nameplate .................... 7
Unit Nameplates .............................................7
Unit Inspection ................................................ 7
Inspection Checklist ........................................7
Loose Parts Inventory .....................................7
Unit Description ............................................... 8
Model Number Coding System .....................8
Unit Model Number ........................................ 8
Table 1. Model Number .................................. 8
Model Number (located on compressor
nameplate) ......................................................12
Table 2. Compressor Model Number .......... 12
Figure 2. Component Location for Typical
RTHD Unit ........................................................ 12
Figure 3. Component Location for Typical
RTHD Unit (Back View) .................................... 13
Figure 4. Component Location for Typical
RTHD Total Heat Reclaim Unit ......................... 14
Figure 5. Component Location for Typical
RTHD Total Heat Reclaim Unit (Back View) ..... 15
Figure 6. Component Location for Typical
RTHD Partial Heat Reclaim Unit ...................... 16
Figure 7. Component Location for Typical
RTHD Partial Heat Reclaim Unit (Back View) .. 17
Installation Overview .....................................17
Table 3. Installation Responsibility Chart for
RTHD Units ...................................................... 18
Table 4. General Data ....................................19
Table 5. General Data ................................... 20
Table 6. General Data ................................... 21
Table 7. General Data ................................... 22
Table 8. General Data ................................... 23
Table 9. General Data ................................... 24
Installation Mechanical ...................................25
Storage ........................................................... 25
Location Requirements ................................. 25
Noise Considerations ...................................25
Foundation ....................................................25
Vibration Eliminators ....................................25
Clearances .....................................................25
Figure 8. Recommended Operating and Ser-
vice Clearances ................................................ 26
Ventilation ......................................................27
Water Drainage .............................................27
Access Restrictions .......................................27
Moving and Rigging .....................................27
Figure 9. Unit Weights and Dimensions for
Rigging 28
Table 10. Unit Weight (lb(kg)) ........................ 29
Table 11. Center of Gravity(in(mm)) .............. 30
Lifting Procedure ........................................... 31
Table 12. Rigging ............................................ 31
Figure 10. Lifting the Unit ................................ 33
Alternate Moving Method ............................33
Isolation Pads ................................................33
Placement Neoprene Isolator Installation
(optional) .......................................................34
Figure 11. Isolator Pad Placement................... 34
Figure 12. Oil Separator with Shipping Bracket
and Compressor Shipping Spacer ................. 35
Unit Leveling .................................................35
Water Piping .................................................. 35
Piping Connections .......................................35
Reversing Water Boxes .................................35
Figure 13. Condenser and Evaporator Water
Connections -BBB ............................................ 36
Figure 14. Condenser and Evaporator Water
Connections -BCD/CCD ................................... 37
Figure 15. Condenser and Evaporator Water
Connections - CEF ............................................ 38
Figure 16. Condenser and Evaporator Water
Connections - CDE/DDE/EDE ........................... 39
Figure 17. Condenser and Evaporator Water
Connections – CFF/DFF/EFF ............................ 40
Figure 18. Condenser and Evaporator Water
Connections - CGG/DGG/EGG ........................ 41
Figure 19. Condenser and Evaporator Water
Connections - BCH ........................................... 42
Figure 20. Condenser and Evaporator Water
Connections - CEJ ............................................ 43
Figure 21. Condenser and Evaporator Water
Connections - CFJ/DFJ ..................................... 44
Figure 22. Condenser and Evaporator Water
Connections - DGK/EGK .................................. 45
Figure 23. Condenser and Evaporator Water

Trane RTHD series Specifications

General

Brand	Trane
Model	RTHD series
Category	Chiller
Language	English