TurboChef i5 Owner's Manual

8 MAINTENANCE
Step 3
Step 4
Step 5
Step 6.1
Step 6.2
Top Jetplate
Daily Maintenance
The following steps will help maintain your oven. Use
only TurboChef Oven Cleaner and Oven Guard. The use
of any other cleaning products can damage critical oven
components, resulting in a non-warranty service call.
Supplies and Equipment
- TurboChef Oven Cleaner (Part Number: 103180)
- TurboChef Oven Guard (Part Number: 103181)
- Nylon scrub pad, cleaning towel, disposable gloves,
protective eyewear, dust mask (optional), pair of tongs
wrapped with towel (optional - see step 11, page 9)
Step 1: Prepare the Oven
WARNING: The oven operates at approximately 500°F (260°C) and may cause injury if not
allowed to cool properly.
- Turn off the oven by touching the Off icon.
- Slightly open the oven door. Cooling takes approximately 40 minutes.
- DO NOT attempt to clean the oven until the oven displays “Oven Off.”
Step 2: Remove and Clean the Wire Rack
WARNING: Be sure the oven interior is cool before you remove the wire rack.
- Wash, rinse, and sanitize the wire rack.
Step 3: Remove and Clean the Lower Jetplate
- Unscrew the two thumb screws on the lower jetplate.
- Lift the lower jetplate by gripping the thumb screws.
- Remove the lower jetplate.
- Wash, rinse, and sanitize the lower jetplate.
CAUTION: DO NOT remove the top ceramic jetplate or glass inserts; breakage
will result in a non-warranty service call.
Step 4: Remove and Clean the Lower Air Diverter
- Remove the lower air diverter.
- Wash, rinse, and sanitize the lower air diverter.
WARNING: DO NOT discard the lower air diverter. The oven will not work
without the lower air diverter installed.
Step 5: Wipe the Oven Interior
- Wipe large particles from the oven interior with a damp towel.
Step 6: Clean the Oven Interior
- Spray oven cleaner onto the top, bottom, and sides of the oven interior.
CAUTION: DO NOT spray oven cleaner into the holes on the back oven wall. Doing so
can damage critical oven components, resulting in a non-warranty service call.
- Allow Oven Cleaner to penetrate stains for five minutes.
- Clean the oven interior with a nylon scrub pad.
NOTE: The i5 oven top jetplate (Figure Step 6.2) is ceramic. The i3 oven top jetplate is
either ceramic or metal with glass inserts.
CAUTION: DO NOT apply pressure to the ceramic or glass portion of the top jetplate
when wiping; breakage will result in a non-warranty service call.
CAUTION: DO NOT remove the top ceramic jetplate or glass inserts; breakage will result
in a non-warranty service call.
Step 1
Step 2

TurboChef i5 Specifications

General

Brand	TurboChef
Model	i5
Category	Oven
Language	English