86
Schematics
Electrical and Pneumatic drawings are provided along with descriptions to assist in troubleshooting the T-
1000-S14.
A. Electrical Drawings
110V Circuit
Circuit drawings are provided to assist in troubleshooting the functionality of the T-1000 and also the
interface signaling with auxiliary infeed equipment.
A circuit diagram of the 110V circuit is comprised of main power to the T-1000, through the fuse,
Corcom filter, motor controller, solid state relay, heater element, line out, and into the power supply
printed circuit board. See Dwg T1kST-E1_110VAC.
Analog Card, Temperature Controller, Heater Circuit
A circuit diagram of the Analog controller FPO-A21 with correct Dip switch settings is provided. See
Dwg T1kST-E32_A21. With a two Thermocouple inputs (TC1, TC2), the analog card has built in PID
and auto tuning functions with 16-bit resolution for very accurate temperature controls. See Dwg T1kST-
E32_A21.
Stepper Motor Circuit
A circuit diagram of the stepper motor controller is provided with correct Dip switch and Pot settings.
See Dwg T1kST-E4.
High Voltage Board Assembly
APPI manufactures the printed circuit board for accurate and consistent perforation detection, for accurate
bag positioning and registration. A circuit diagram is provided for this PCB.
Aux Interface
APPI provides for a closed loop signal with auxiliary infeed equipment. The circuit diagram references
the pinouts on Aux 2 connector, located on the T-1000 rear electrical panel (military connector). See
Dwg T1kST-E7.
Solenoid Valve Circuit Diagram
The T-1000 is equipped with an expandable Valve manifold, pre-wired for up to 7 options solenoid
valves. Valve stations 1 through 4 are standard, and valve station 5-11 are options. PLC output
information, DB25 pin outs, voltages and valve descriptions are provided on this circuit diagram. See
Dwg T1kST-E8.
PLC Expansion Inputs and Outputs
The T-1000 comes equipped with a PLC Expansion, where standard options are wired into the bagger.
See T1kST-E10_EXP-IO.
DB connector circuit drawing
T1kST-E14_DBCon
Panasonic Light Curtain SF4C
The T-1000 has the option of having a light curtain installed as an extra safety measure. See T1kST-
E34_LC_Panasonic SF4C.
Barcode Verifier
The T-1000-S14 has the option of a Barcode Verifier installed to scan labels. See T1kST-
E35_BCV_Keyence SR.
To Next Page
Loading...
