AVANT e5 - 6. Hydraulic oil change

Avant e5
78
.
5. Hydraulic oil level
Hydraulic oil level can be checked with the dipstick in
the filler. Lock the boom with boom service support
to access the filler opening.
Oil level should be approximately at the lower mark
of the dipstick (1) when the loader boom is up.
Tighten the dipstick on its threads for measurement.
Refill when necessary, but never exceed the upper
limit mark (2). Doing so can cause oil to overflow
when lowering the boom.
.
..
1.
Target marker. Fill to this
mark when hydraulic
system is cold.
The area highlighted in
the adjacent figure
shows approximately the
acceptable level.
2.
The second mark on the
dipstick indicates max
level of hydraulic oil. Oil
can reach this level
when hydraulic system
is hot.
Never overfill the
hydraulic oil tank. Oil
can flow over, or foam
inside tank.
.
6. Hydraulic oil change
When changing hydraulic oil, the oil can be removed
with a suction pump from the filler opening, or by
removing the drain plug on the right side of the front
frame, close to the articulation joint. In both cases it
is important to clean the magnetic drain plug.
Hydraulic oil tank capacity is 36 l.
Hydraulic oil type
Always use correct type of clean, high quality ISO
VG-46 certified mineral hydraulic oil. If ambient
temperature is hot, higher viscosity oil may be
required, contact dealer.
In freezing temperatures use oil designed for the
purpose, in order that the machine operates as
intended and starting is easier.
Use of synthetic or bio hydraulic fluids
may cause premature wear or
damage to the hydraulic components
and is not permitted. Using wrong
type of hydraulic oil will void the
warranty.
7. Changing of hydraulic oil filter
The loader is equipped with a hydraulic oil return
filter. It is located on top of the hydraulic tank, next to
the dipstick. Take off the cover and replace the oil
filter cartridge. Dispose used filters as instructed by
your local authorities. Never throw oil filters in
general trash.
Filters - list of filters
Filters for Avant e5
Hydraulic oil return filter
74093
https://tractormanualz.com