xiii
62−11389
LIST OF ILLUSTRATIONS − Continued
FIGURE NUMBER Page
Figure 8−17 Engine Crankcase Breather 8−14........................................................
Figure 8−18 Refrigerant System Service Equipment 8−15...............................................
Figure 8−19 Compressor - model 06D 8−21...........................................................
Figure 8−20 Cylinder Head & Valve Plate 8−22........................................................
Figure 8−21 Checking Suction Valve 8−23............................................................
Figure 8−22 Oil Pump and Bearing Head Assembly 8−23...............................................
Figure 8−23 Oil Pump 8−24.........................................................................
Figure 8−24 Unloader Coil 8−25.....................................................................
Figure 8−25 Condenser/Radiator Assembly 8−27......................................................
Figure 8−26 Suction modulation valve (CSMV) 8−28...................................................
Figure 8−27 CSMV Coil 8−29.......................................................................
Figure 8−28 Electronic expansion valve 8−30.........................................................
Figure 8−29 Electronic Expansion Valve 8−30.........................................................
Figure 8−30 Typical Setup for Testing High Pressure Switch 8−31........................................
Figure 8−31 Defrost Air Switch Test Setup 8−32.......................................................
Figure 8−32 Megohmmeter Connection to Ground Plate 8−33...........................................
Figure 8−33 High Voltage Contactors 8−33...........................................................
Figure 8−34 Light Bar Connections 8−34.............................................................
Figure 8−35 Overload Ground Fault Connections 8−34.................................................
Figure 8−36 Evaporator Blower Assembly 8−35.......................................................
Figure 8−37 Condenser Fan Assembly 8−36..........................................................
Figure 8−38 Generator Assembly 8−40...............................................................
Figure 8−39 Bolt Hole Pattern For Bell Housing and Crankshaft 8−40.....................................
Figure 9−1 ENSCU Diagnostic Tree - 1 Long, 1 Short LED Code 9−9...................................
Figure 9−2 ENSCU Diagnostic Tree - 2 Long, 1 Short LED Code 9−10...................................
Figure 9−3 ENSCU Diagnostic Tree - 2 Long, 3 Short LED Code 9−11...................................
Figure 9−4 ENSCU Diagnostic Tree - 2 Long, 7 Short LED Code 9−12...................................
Figure 9−5 Micro Diagnostic Tree - Condition 1 - Main Power Switch On - Unit Does Not Operate 9−14.......
Figure 9−6 Micro Diagnostic Tree - Condition 2 - Main Power Switch On - Unit Operates But Not Properly 9−15
Figure 9−7 Micro Diagnostic Tree - Condition 3 - Main Power Switch Off - Unit Fails To Stop 9−16............
Figure 9−8 Micro Diagnostic Tree - Condition 4 - Unit Will Not Run In High Speed 9−17.....................
Figure 9−9 Micro Diagnostic Tree - Condition 5 - Unit Will Not Run In Low Speed 9−18.....................
Figure 9−10 Micro Diagnostic Tree - Condition 6 - DataLink Data Recorder Data Download
Problems When Using ReeferManager and a Download Cable. Data File Analysis
Problems Using Reports 9−19..........................................................
Figure 9−11 Microprocessor Diagnostic Tree - Condition 7 - PC Card Problems 9−20.......................
Figure 9−12 Micro Diagnostic Tree - Condition 8 - Programming Problems With PC Cards 9−21.............
To Next Page