NOTE: An Authorization is required from Cub Cadet before the batteries can be replaced under warranty. This
check list must be performed prior to calling Cub Cadet for an authorization number and returned with the
old batteries. The battery pack is not considered bad until they fall below 30 AH (50% of the 1 hour rat
-
ing).
NOTE: The battery charger must be evaluated with the mower for warranty authorization.
NOTE: Detailed battery testing instructions can be found in the RZT-S Zero Shop Manual form # 769-08008.
Date batteries were installed ______________
Customer Complaint __________________________________________________________________________
Authorization number _________________ Technician’s signature _____________________________________
Grass Height _________________ Prior to testing the batteries were:
fully charged Y N
Type of grass _________________ completely discharged Y N
Run time per charge ____________ How many hours did the charger
_____ run and could not complete a charge
_____ Test run the mower Check for any charger trouble codes (refer
_____ to back of sheet for trouble codes)
_____ Check the VCM for fault codes _____ Inspect the mowing blades
_____ Repair any fault codes found NOTE: Dull blades will greatly reduce run
time while mowing
_____ Connect the mower’s charger to the mower _____ Inspect all battery connections
NOTE: T h e c u s t o m e r ’ s c h a r g e r m u s t b e u s e d i n
this step to rule out a bad charger
_____ Ambient air temperature
_____ Inspect the fuses
_____ Check/adjust the brake gap
Capacity/Discharge tester used make/model
_____________________________________
_____ Connect the charger to an approved AC power
source Amp Hour reading from tester ______________
Battery Position Battery serial number Battery code
Front
Middle
Left rear
Right rear
ELECTRIC RIDER BATTERY REPLACEMENT CHECK LIST
Dealer number _____________ Technician_____________________________ Inspection Date_________
Model number_____________________ Serial number__________________________ Hours __________
To Next Page
Loading...
Need help?
General
