SCS Overview Manual i
TABLE OF CONTENTS
List of Figures/Tables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . iii
List of Tables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .v
1: Introduction
How to Use This Manual. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
Who should read this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
General Warnings and Cautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
Conventions used in this manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Safety warning label. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Equipment labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
Instructional symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
SpectraSensors Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
Manufacturer Address . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-4
2: Safety
Potential Risks Affecting Personnel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Personnel responsibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Mitigating risks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Exposure to process gases . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Electrocution hazard. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Explosion hazard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
3: Sample Conditioning System
About the SCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Typical SCS Component Overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
SCS filters. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Sample transport tubing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Sample bypass flow control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
SCS pressure regulator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Sample flow controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Sample dryer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Validation systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Sample return/vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
SCS heaters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
To connect electrical power to the enclosure heater . . . . . . . . . . . . . . . . . . . 3-3
Checking the SCS Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
To perform SCS installation checks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Starting up the SCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
To prepare for SCS startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
To start up the field pressure reducing station. . . . . . . . . . . . . . . . . . . . . . . 3-7
To start up the sample bypass stream on process sample. . . . . . . . . . . . . . . 3-7
To start up the analyzer on process sample . . . . . . . . . . . . . . . . . . . . . . . . 3-8
To start up the sample system heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-9
Shutting Down the SCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-10
To isolate the measurement sample cell for short-term shutdown . . . . . . . . 3-10
To isolate the SCS for short-term shutdown . . . . . . . . . . . . . . . . . . . . . . . 3-11
To isolate the process sample tap for long-term shutdown . . . . . . . . . . . . . 3-12
Powering Down the Analyzer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
To power down the analyzer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
To purge the analyzer for shipment/relocation. . . . . . . . . . . . . . . . . . . . . . 3-13
Periodic SCS Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-14
Regular SCS status check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15
To check the filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-15