HERO DUET - Tyre Repair and Replacement Procedures

23
The recommended tyre for your vehicle are:
Rear : 90/100x10-53J (Tubeless Tyre)
Front : 90/100x10-53J (Tubeless Tyre)
Ÿ Do not install a tube inside a tubeless tyre on
this vehicle. Excessive heat buildup can
cause the tube to burst.
Ÿ Use only tubeless tyres on this vehicle. The
rims are designed for tubeless tyres and
during hard acceleration or braking, a tube-
type tyre could slip on the rim and cause the
tyre to rapidly deflate.
Important safety reminders
NOTE
The imported tyre(s) if fitted without ISI mark;
are in compliance of BIS standard and Central
Motor Vehicle Rules 1989, as declared by the
Tyre manufacturer.
WARNING
!!
Ÿ Under-inflation may result in the tyre
slipping on or tyre coming off the rim.
Ÿ Always use the size and type of tyres
recommended in this owner's manual.
Ÿ Follow all instruction in this owner’s manual
regarding tyre inflation and maintenance.
Ÿ Riding on tyres that are excessively worn or
improperly inflated can cause a crash in
which you can be seriously hurt and killed.
Ÿ Operation with excessively worn tyres is
hazardous and will adversely affect traction
and handling.
NOTE
For repair and replacement of tyre it is advised
to visit your Authorised Hero MotoCorp
workshop.
The tyres that were installed on your vehicle
were designed to match the performance
capabilities of your vehicle and provide the
best combination of handling, braking,
durability and comfort.
Tyre replacement
Unidirectional tyres
Whenever the tyre is removed and put back in
case of puncture, ensure the arrow mark (2)
on the tyre is in the same direction as that of
forward rotation of wheel.
Tyre repair
Repairing a puncture or removing a wheel
requires special tools and technical expertise.
If a tyre is punctured or damaged, it is advised
to visit nearest tyre manufacture, Hero
MotoCorp authorised dealer/workshop or the
tyre repair shop who has expertise in
repairing methods of tubeless tyre.
A tyre that is repaired either temporarily or
permanently, will have lower speed and
performance limits than a new tyre. After an
emergency repair, always have the tyre
inspected/replaced at our authorised dealer
and replace the tyre if suggested.
You should not exceed 70 km/hour for the
1st 24 hours or 105 km/hour at any time
thereafter. In addition, you may not be able to
safely carry as much load as with a new tyre.
If you decide to have a tyre replace be sure the
wheel is balanced before you ride.