the key when attempting to make the
following checks and changes.
Never fail to check the fuel lines
periodically the fuel lines are subject to
wear and aging fuel may leak out onto
the running engine causing a fire.
The fuel line connections should be
checked annually or every 100 service
hours whichever comes first.
1. Park the vehicle on a flat surface and tilt
the cargo bed.
2. The fuel line is made of rubble and ages
regardless of service period.
3. If the fuel line and clamps are found to be
damaged or deteriorated replace them.
4. Check fuel filter if it is clogged by debris or
contaminated with water replace it.
IMPORTANT
When the fuel line is disconnected for
maintenance or repair, close both ends of the
fuel line with a piece of clean cloth or paper to
prevent dust and dirt from entering. Particular,
care must be taken not to admit dust and dirt
into the fuel pump entrance. Even a small
amount of dust or dirt will cause premature
wear and malfunction of the fuel pump and
injector components.
① Pipe clamp ② fuel line
③ fuel pump
■ Checking battery condition
DANGER
If you store a battery in a diminished state
of charge you will probably have to replace
the battery.
CAUTION
To avoid personal injury
Never remove the battery while the
engine is running.
Keep electrolyte away from eyes,
hands and clothes. If you are spattered
with it, wash it away completely with
water immediately and get medical
attention.
Wear eye protection and rubber gloves
when working around the battery.
The factory –installed battery is non-refillable
type if the battery is weak, charge the battery
or replace it with new one
◆ Battery charging
CAUTION
To avoid personal injury
When the battery is being activated,
hydrogen and oxygen gases in the
battery are extremely explosive. keep
open sparks and flames away from the
battery at all times, especially when
To Next Page
Loading...
