Magnetek XLTX - Battery Disposal; Crane;Lifting Device Specific Warnings

Engineered XLTX Transmitter Instruction Manual
December 2016
Page 10 of 49
2.8 BATTERY DISPOSAL
Before disposing of batteries consult local and governmental regulatory requirements for proper disposal
procedure.
2.9 CRANE /LIFTING DEVICE SPECIFIC WARNINGS
WARNING
ALL EQUIPMENT MUST HAVE A MAINLINE CONTACTOR INSTALLED AND ALL TRACKED CRANES,
HOISTS, LIFTING DEVICES AND SIMILAR EQUIPMENT MUST HAVE A BRAKE INSTALLED. FAILURE
TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY OR DEATH AND DAMAGE TO
EQUIPMENT.
AN AUDIBLE AND/OR VISUAL WARNING MEANS MUST BE PROVIDED ON ALL REMOTE
CONTROLLED EQUIPMENT AS REQUIRED BY CODE, REGULATION, OR INDUSTRY STANDARD.
THESE AUDIBLE AND/OR VISUAL WARNING DEVICES MUST MEET ALL GOVERNMENTAL
REQUIREMENTS. FAILURE TO FOLLOW THIS WARNING COULD RESULT IN SERIOUS INJURY OR
DEATH AND DAMAGE TO EQUIPMENT.
THE DIRECT OUTPUTS OF THIS PRODUCT ARE NOT DESIGNED TO INTERFACE DIRECTLY TO TWO
STATE SAFETY CRITICAL MAINTAINED FUNCTIONS, I.E., MAGNETS, VACUUM LIFTS, PUMPS,
EMERGENCY EQUIPMENT, ETC. A MECHANICALLY LOCKING INTERMEDIATE RELAY SYSTEM
WITH SEPARATE POWER CONSIDERATIONS MUST BE PROVIDED. FAILURE TO FOLLOW THIS
WARNING COULD RESULT IN SERIOUS INJURY OR DEATH OR DAMAGE TO EQUIPMENT.
Cranes, hoists, lifting devices and other material handling equipment can be large, and operate at high
speeds.
The operator should:
 continuously watch and monitor status of lifted loads
 know and follow cable and hook inspection procedures
The operator shall not:
 lift or move more than the rated load
 use the crane, hoist or lifting device to lift, support or transport people
 lift or carry any loads over people
 operate the crane, hoist or lifting device unless all persons, including the operator, are and remain
clear of the supported load and any potential pinch points
 operate a crane, hoist or lifting device when the device is not centered over the load
 operate a crane, hoist or lifting device if the chain or wire rope is not seated properly in the
sprockets, drum or sheave
 leave any load unattended while lifted