Mase Generators SILENT 12 - Page 31

SILENT 12
31
GB
4.3 Trouble-shooting
FAULT CAUSE
THE
GENERATOR IS
NOT ENERGISED
HIGH VOLTAGE
IN IDLE
LOW VOLTAGE
IN IDLE
EXACT VOLTAGE
IN IDLE BUT
LOW AT FULL
POWER
EXACT VOLTAGE
IN IDLE BUT
HIGH AT FULL
POWER
VOLTAGE
INSTABLE
LOW ENGINE RPM
zz
WINDING FAULTY
z
HIGH ENGINE RPM ROTOR DIODES FAULTY
z
WINDINGS FAULTY
z
LOW ENGINE RPM AT FULL POWER z TOO HIGH LOAD
z
LOOSE CONTACTS
z
IRREGULAR ENGINE RPM z NULL RESIDUAL MAGNETISM
z
VOLTAGE REGULATOR
zzzzz
VOLTAGE REGULATOR zz VOLTAGE REGULATOR FUSE BROKEN
z
FAULT CAUSE
NO
VOLTAGE
12V
MODULE
DOES NOT
COME ON
THE
GENERATOR
DOES NOT
START
THE
GENERATOR STARTS AND
THEN SWITCHES
OFF
THE
GENERATOR
DOES NOT
SWITCH OFF
CONNECTIONS INTERRUPTED
zzzz
BATTERY CHARGER ALTERNATOR FAULTY
zz
12 V THERMAL SWITCH TRIPPED zzz BATTERY FAULTY
zzz
MODULE FUSE BLOWN
zz
START/STOP BUTTON FAULTY zzzz ALARM ACTIVE ON MODULE
z
PROTECTION MODULE FAULTY
zzzz
ELECTROMAGNET FAULTY
zzz
FUEL PUMP FAULTY
zz
OIL PRESSURE SWITCH FAULTY
z
STARTER MOTOR FAULTY
z
ELECTRICAL SYSTEM
STARTING AND STOPPING PROBLEMS
VOLTAGE DELIVERY PROBLEMS
ALTERNATOR
REMEDIES
CHECK THE RPM AND SET TO THE RATED VALUE CHECK THE WINDING RESISTOR CHECK THE RPM AND SET TO THE RATED VALUE CHECK AND REPLACE CHECK THE WINDING RESISTORS CHECK RPM AND ADJUST CHECK AND ADJUST CHECK THE CONNECTIONS CHECK ENGINE RPM RE-ENERGISE THE GENERATOR RECALIBRATE THE "VOLT" POTENTIOMETER OR REPLACE RECALIBRATE THE "STAB" POTENTIOMETER CHECK AND REPLACE
REMEDIES
CHECK THE CONNECTIONS CHECK OR REPLACE RESET CHECK OR REPLACE CHECK OR REPLACE CHECK OR REPLACE RESET ALARM CHECK CHECK OR REPLACE CHECK OR REPLACE CHECK OR REPLACE CHECK OR REPLACE
4 ENGINE