MDC XT13 - Page 97

96 | Page
www.mdcusa.co m
I
Ph: 833-632-8721
I
Page | 96
Every 6 MONTHS / 3000 mile SERVICE CHECKED
Hitch
• Check hitch bolts to 90Nm/66ft lb.
• Lubricate
Handbrake
• Check cable and adjust if necessary
Hand winch
• Check brake function and webbing
Suspension
• Torque bolts to 190Nm/140ft lb
• Grease bushes and check for play.
• Check retaining chain shackles tight.
• Inspect shock absorber for condition.
• Inspect shock absorber bushes
Brakes
• Inspect and adjust. Check lining thickness and drum wear
Wheel bearings
• Remove, clean and re-lubricate. Inspect for wear and replace if
necessary
Wheel Nuts
• Inspect condition and torque to (125Nm/92ft lb ½” studs)
(140Nm/103ft lb 14mm studs alloy rims) (200Nm/148ft lb 14mm
studs steel rims)
Tires
• Inspect for abnormal wear, damage, and pressure
Lights • Check all lights are functioning
Battery
• Check terminals and voltage at full charge
Seals
• Check condition and correct latch/lock adjustment for correct 30-50%
compression
General fixings
• Check all structural fixing are secure.
Seals & Latches
• Check all seals on doors and hatches compress 30-50%. All seals in
serviceable condition and free of damage.
Suspension
• Grease bushes and check for play.
• Check torque on suspension hanger bolts (190nm)
• Check retaining chain shackles tight.
Service Centre:
Notes:
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________