Midmark M9 - Table of Contents; Section;Paragraph

Section/Paragraph Page
TABLE OF CONTENTS
Section/Paragraph Page
IMPORTANT INSTRUCTIONS
General Safety Instructions......................................... iii
Safety Alert Symbols .................................................. iii
Warranty Instructions .................................................. iii
SECTION I GENERAL INFORMATION
1.1 Model / Serial Number Location................... 1-1
1.2 Specifications .............................................. 1-1
1.3 Description of Normal Operation .................. 1-2
1.4 Ordering Parts ............................................. 1-3
1.5 Special Tools .............................................. 1-4
SECTION II TESTING AND TROUBLESHOOTING
2.1 Operational Test .......................................... 2-1
2.2 Troubleshooting Procedures ........................ 2-1
SECTION III SCHEDULED MAINTENANCE
3.1 Scheduled Maintenance .............................. 3-1
SECTION IV MAINTENANCE/SERVICE
INSTRUCTIONS
4.1 Safety Precautions...................................... 4-1
4.2 Top Cover Removal / Installation ................ 4-1
4.3 Right Hand Side Panel Removal /
Installation .............................................. 4-1
4.4 Left Hand Side Panel Removal /
Installation .............................................. 4-2
4.5 Back Panel Removal/Installation ................. 4-3
4.6 Base Inspection Cover Removal /
Installation .............................................. 4-3
4.7 Bellows Assembly Removal / Installation .... 4-4
4.8 Condensing Tank Water Level Sensor
Removal / Installation ............................. 4-5
4.9 Temperature Sensor Assembly
Removal / Installation ............................. 4-6
4.10 Pressure Vessel Water Level Sensor
Removal / Installation ............................. 4-6
4.11 Vent Solenoid Removal / Installation ........... 4-7
4.12 Fill Solenoid Removal / Installation ............. 4-9
4.13 Control PC Board Removal / Installation ... 4-10
4.14 Door Switch Removal / Installation ............ 4-13
4.15 Pulse Solenoid Removal / Installation ....... 4-13
4.16 Thermostat Removal / Installation ............. 4-14
4.17 Wire Tray Rack and Tray Plate
Removal / Installation ........................... 4-15
4.18 Heating Element and Gasket
Removal / Installation ........................... 4-15
4.19 Filter Removal / Installation ....................... 4-16
4.20 Door Gaskets Removal / Installation ......... 4-17
4.21 Display PC Board Removal / Installation ... 4-17
4.22 Condensing Tank Assembly
Removal / Installation ........................... 4-18
4.23 Pressure Relief Valve Removal /
Installation ............................................. 4-19
4.24 Pressure / Temperature Potentiometers
Adjustments ......................................... 4-20
4.25 Display PC Board Lamp / Display /
Button Check ........................................ 4-23
4.26 Pressure Relief Valve Check..................... 4-24
4.27 Dry Cycle Dip Switches Adjustment ........... 4-25
4.28 M9 / M11 Door Opening Test ..................... 4-26
SECTION V SCHEMATICS AND DIAGRAMS
5.1 Wiring Diagrams .......................................... 5-1
5.2 Flow Diagram ............................................ 5-11
5.3 Pressure / Temperature Chart .................... 5-12
SECTION VI PARTS LIST
6.1 Description of Bullets ................................... 6-1
6.2 Torque Specifications and Important
Assembly Notes ...................................... 6-1
NOTE:
The Parts List in this manual is divided
into two sections [M9 / M9D & M11/M11D].
Verify model and refer to appropriate section.
M9 / M9D Parts List
M9 Component / Page Cross-Reference ..... 6-2
M9D Component / Page Cross-Reference .... 6-3
Main Enclosure Components ...................... 6-4*
Plumbing and Sensor Components ............ 6-5*
Pressure Vessel Components .................... 6-6*
M9 Manifold Components ........................... 6-7*
M9D Manifold Components ........................ 6-8*
Electrical Components ............................... 6-9*
M9 / M9D Control PC Board ...................... 6-10
M9 Labels and Decals ............................... 6-11
M9D Labels and Decals ............................ 6-12
Printer Components .................................. 6-13
Racks, Trays, and Cleaner ....................... 6-14*
Packaging ................................................. 6-15
(*) Indicates that there has been a serial number break for the illustration
and that there are additional point page(s) following the original page.
© Midmark Corporation 2002 SF-1827 Page i Printed in U.S.A.